Search Legislation

The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 2008

Status:

This is the original version (as it was originally made). This item of legislation is currently only available in its original format.

Statutory Instruments

2008 No. 2337

Health And Safety

The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 2008

Made

1st September 2008

Laid before Parliament

5th September 2008

Coming into force

1st October 2008

The Secretary of State is a Minister designated for the purpose of section 2(2) of the European Communities Act 1972(1) in relation to the regulation and control of classification, packaging and labelling of dangerous substances and preparations(2), and for measures relating to consumer protection(3).

The Secretary of State makes these Regulations—

(a)

in exercise of the powers conferred upon him by section 2(2) of that Act and by section 15(1), (2), (3)(a) and (c), (4)(a)(4) and (b) of, and paragraphs 1(1)(b) and (4) and 3(2) of Schedule 3 to, the Health and Safety at Work etc. Act 1974(5) (“the 1974 Act”); and

(b)

for the purpose of giving effect without modifications to proposals submitted to him by the Health and Safety Executive under section 11(3)(6) of the 1974 Act after the carrying out by the said Executive of consultations in accordance with section 50(3) of that Act.

Citation, commencement and interpretation

1.—(1) These Regulations may be cited as the Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 2008 and shall come into force on 1st October 2008.

(2) In these Regulations, “the principal Regulations” means the Chemicals (Hazard Information and Packaging for Supply) Regulations 2002(7).

Amendments to regulation 2 of the principal Regulations

2.  In regulation 2(1) of the principal Regulations—

(a)for the definition of “the approved classification and labelling guide” substitute—

“the approved classification and labelling guide” means the guide entitled “Approved Guide to the Classification and Labelling of Dangerous Substances and Dangerous Preparations (Fifth Edition)” approved by the Health and Safety Commission on 16th April 2002(8),as revised or re-issued from time to time,; and

(b)for the definition of “the approved supply list” substitute—

“the approved supply list” means the document entitled “Information approved for the Classification and Labelling of Dangerous Substances and Dangerous Preparations (Eighth Edition)” approved by the Health and Safety Commission on 26 July 2005(9), as revised or re-issued from time to time,.

Amendments to regulations 8A and 9 of the principal Regulations

3.—(1) In regulation 8A(4) of the principal Regulations after the words “this regulation” add the words “and regulation 9(2)”.

(2) In regulation 9(2) of the principal Regulations—

(a)For the words “regulations 8 and 8A” substitute the words “paragraph (2A)”; and

(b)After paragraph (2) add—

(2A) Where a package would be required to be labelled and marked in accordance with any of the national or international transport rules listed in regulation 8A(4) and the package consists of one or more receptacles in outer packagings, it shall be sufficient compliance with paragraph (2) if the package shows the labels and markings required by whichever of the national or international rules is appropriate..

Amendments to Schedule 3 of the principal Regulations

4.  Schedule 3 to the principal Regulations shall be amended in accordance with the following paragraphs—

(a)in Part I omit paragraph 19(2);

(b)in Part II Tables II and IIA omit in both footnotes marked with a dagger the words “carcinogenic or”;

(c)for Part II Table VI substitute the Table VI contained in Schedule 1 to these Regulations;

(d)for Part II Table VIA substitute the Table VIA contained in Schedule 1 to these Regulations;

(e)for Part III Tables 1 and 2 substitute Tables 1a, 1b and 2 contained in Schedule 2 to these Regulations; and

(f)for Part III Table 5 substitute the Table contained in Schedule 3 to these Regulations.

Amendments to Schedule 5 of the principal Regulations

5.  For Schedule 5 Part II of the principal Regulations substitute the Part II contained in Schedule 4 to these Regulations.

Amendments to the Chemicals (Hazard Information and Packaging for Supply)(Amendment) Regulations 2005

6.  In the Chemicals (Hazard Information and Packaging for Supply)(Amendment) Regulations 2005(10) omit regulation 2(2)(b), (4), (5) and (6).

Amendments to the Control of Major Accident Hazards Regulations 1999

7.  For regulation 20(6) of the Control of Major Accident Hazards Regulations 1999(11) substitute the following paragraph—

(6) Notwithstanding the Health and Safety (Enforcing Authority) Regulations 1998, the Executive shall, for the purposes of the 1974 Act, be the enforcing authority for the relevant statutory provisions at an establishment to which any of these Regulations apply, unless a transfer of responsibility is made under paragraph (7) below.

(7) The responsibility, for the purposes of the 1974 Act, for enforcing any of the relevant statutory provisions at any establishment to which any of these Regulations apply may be transferred from the Executive to the local authority, insofar as the main activity carried on at that establishment is the sale of goods, or the storage of goods for retail or wholesale distribution, except—

(a)at container depots where the main activity is the storage of goods in the course of transit to or from dock premises, an airport or a railway;

(b)where the main activity is the sale or storage for wholesale distribution of any substance or preparation dangerous for supply, or

(c)where the main activity is the sale or storage of water or sewage or their by-products or natural or town gas.

(8) A transfer may be made only by agreement between the Executive and the local authority.

(9) Where a transfer has been made, the local authority shall cause notice of the transfer to be given to persons affected by it..

Signed by the authority of the Secretary of State for Work and Pensions

William D.McKenzie

Parliamentary Under-Secretary of State

Department for Work and Pensions

1st September 2008

Regulation 4(c) and (d)

SCHEDULE 1

Table VI

Classification of the substanceClassification of the preparation
Categories 1 and 2Category 3
(*)

In cases where the preparation is assigned R49 and R40, both R phrases shall be kept, because R40 does not distinguish between the exposure routes, whereas R49 is only assigned for the inhalation route.

(**)

R68 here refers to substances classified as mutagenic. Concentration limits for substances required to be labelled R68 but classified as harmful are given in Table II.

Carcinogenic substances of category 1 or 2 with R45 or R49

Concentration ≥ 0.1% carcinogenic

R45, R49 obligatory as appropriate

Carcinogenic substances of category 3 with R40

Concentration ≥ 1% carcinogenic

R40 obligatory (unless already assigned R45(*))

Mutagenic substances of category 1 or 2 with R46

Concentration ≥ 0.1% mutagenic

R46 obligatory

Mutagenic substances of category 3 with R68(**)

Concentration ≥ 1% mutagenic

R68(**) obligatory (unless already assigned R46)

Substances “toxic for reproduction” of category 1 or 2 with R60 (fertility)

Concentration ≥ 0.5%

toxic for reproduction (fertility)

R60 obligatory

Substances “toxic for reproduction” of category 3 with R62 (fertility)

Concentration ≥ 5%

toxic for reproduction (fertility)

R62 obligatory (unless already assigned R60)

Substances “toxic for reproduction” of category 1 or 2 with R61 (development)

Concentration ≥ 0.5%

toxic for reproduction (development)

R61 obligatory

Substances “toxic for reproduction” of category 3 with R63 (development)

Concentration ≥ 5%

toxic for reproduction (development)

R63 obligatory (unless already assigned R61)

Table VIA

Classification of the substance (gas)Classification of the gaseous preparation
Categories 1 and 2Category 3
(*)

In cases where the preparation is assigned R49 and R40, both R phrases shall be kept, because R40 does not distinguish between the exposure routes, whereas R49 is only assigned for the inhalation route.

(**)

R68 here refers to substances classified as mutagenic. Concentration limits for substances required to be labelled R68 but classified as harmful are given in Table IIA.

Carcinogenic substances of category 1 or 2 with R45 or R49

Concentration ≥ 0.1% carcinogenic

R45, R49 obligatory as appropriate

Carcinogenic substances of category 3 with R40

Concentration ≥ 1% carcinogenic

R40 obligatory (unless already assigned R45(*))

Mutagenic substances of category 1 or 2 with R46

Concentration ≥ 0.1% mutagenic

R46 obligatory

Mutagenic substances of category 3 with R68(**)

Concentration ≥ 1% mutagenic

R68(**) obligatory (unless already assigned R46)

Substances “toxic for reproduction” of category 1 or 2 with R60 (fertility)

Concentration ≥ 0.2%

toxic for reproduction (fertility)

R60 obligatory

Substances “toxic for reproduction” of category 3 with R62 (fertility)

Concentration ≥ 1%

toxic for reproduction (fertility)

R62 obligatory (unless already assigned R60)

Substances “toxic for reproduction” of category 1 or 2 with R61 (development)

Concentration ≥ 0.2%

toxic for reproduction (development)

R61 obligatory

Substances “toxic for reproduction” of category 3 with R63 (development)

Concentration ≥ 1%

toxic for reproduction (development)

R63 obligatory (unless already assigned R61)

Regulation 4(e)

SCHEDULE 2

Table 1a

Acute aquatic toxicity and long-term adverse effects

Classification of the substanceClassification of the preparation
N, R50-53N, R51-53R52-53
For preparations containing a substance classified with N, R50-53, the concentration limits and the resulting classification given in table 1b are applicable.
N, R50-53see Table 1bsee Table 1bsee Table 1b
N, R51-53Cn ≥ 25%2.5% ≤ Cn < 25%
R52-53Cn ≥ 25%

Table 1b

Acute aquatic toxicity and long-term adverse effects of substance very toxic to the aquatic environment

LC50 or EC50 value (“L(E)C50”) of substance classified as N, R50-53 (mg/l)Classification of the preparation
N, R50-53N, R51-53R52-53
For preparations containing substances with a lower LC50 or EC50 value than 0.00001 mg/l, the corresponding concentration limits are calculated accordingly (in factor 10 intervals).
0.1 < L(E)C50 ≤ 1Cn ≥ 25%2.5% ≤ Cn < 25%0.25% ≤ Cn < 2.5%
0.01 < L(E)C50 ≤ 0.1Cn ≥ 2.5%0.25% ≤ Cn < 2.5%0.025% ≤ Cn < 0.25%
0.001 < L(E)C50 ≤ 0.01Cn ≥ 0.25%0.025% ≤ Cn < 0.25%0.0025% ≤ Cn < 0.025%
0.0001 < L(E)C50 ≤ 0.001Cn ≥ 0.025%0.0025% ≤ Cn < 0.025%0.00025% ≤ Cn < 0.0025%
0.00001 < L(E)C50 ≤ 0.0001Cn ≥ 0.0025%0.00025% ≤ Cn < 0.0025%0.000025% ≤ Cn < 0.00025%

Table 2

Acute aquatic toxicity

LC50 or EC50 value (“L(E)C50”) of substance classified either as N, R50 or as N,R50-53 (mg/l)Classification of the preparation N, R50
For preparations containing substances with a lower LC50 or EC50 value than 0.00001 mg/l, the corresponding concentration limits are calculated accordingly (in factor 10 intervals).
0.1 < L(E)C50 ≤ 1Cn ≥ 25%
0.01 < L(E)C50 ≤ 0.1Cn ≥ 2.5%
0.001 < L(E)C50 ≤ 0.01Cn ≥ 0.25%
0.0001 < L(E)C50 ≤ 0.001Cn ≥ 0.025%
0.00001 < L(E)C50 ≤ 0.0001Cn ≥ 0.0025%

Regulation 4(f)

SCHEDULE 3

Table 5

Dangerous for the ozone layer

Classification of the substanceClassification of preparation N, R59
N with R59Cn ≥ 0.1%

Regulation 5

SCHEDULE 4

PART IIPARTICULAR PROVISIONS CONCERNING CERTAIN PREPARATIONS

ASPECIAL PROVISIONS FOR DANGEROUS PREPARATIONS

Dangerous preparations to be supplied to the general public

1.(1) The label on the packaging of dangerous preparations intended to be supplied to the general public must in addition to the relevant safety advice bear the relevant safety phrase S1, S2, S45 or S46 in accordance with the approved classification and labelling guide.

(2) When the dangerous preparations referred to in sub-paragraph (1) are classified as very toxic, toxic or corrosive and where it is physically impossible to give the information on the package itself, packages containing such preparations must be accompanied by precise and easily understandable instructions for use including, where appropriate, instructions for the destruction of the empty package.

Dangerous preparations intended for use by spraying

2.  The label on the packaging containing dangerous preparations intended to be used for spraying shall bear the safety phrase S23 and safety phrase S38 or S51 assigned in accordance with the approved classification and labelling guide.

Dangerous preparations containing a substance affected by the risk phrase R33 (danger of cumulative effects)

3.  When a dangerous preparation contains at least one substance required to show the risk phrase R33, that phrase must be shown on the label on the packaging of the dangerous preparation when the concentration of that substance is equal to or higher than 1% unless a different value is shown for that substance in the approved supply list.

Dangerous preparations containing a substance affected by the risk phrase R64 (may cause harm to breast-fed babies)

4.  When a dangerous preparation contains at least one substance required to show the risk phrase R64, that phrase must be shown on the label on the packaging of the dangerous preparation when the concentration of that substance is equal to or higher than 1% unless a different value is shown for that substance in the approved supply list.

BSPECIAL PROVISIONS APPLYING TO ANY PREPARATION

Paints and varnishes containing lead

1.(1) The label on the packaging of paints and varnishes containing lead in quantities exceeding 0.15% (expressed as weight of lead out of the total weight of the preparation and determined in accordance with ISO Standard 6503/1984) shall bear the following inscription–

Contains lead. Should not be used on surfaces that are liable to be chewed or sucked by children..

(2) In the case of packages containing less than 125 millilitres of the preparations referred to in sub-paragraph (1), the inscription on the label may be–

Warning! Contains lead..

Cyanoacrylate based adhesives

2.(1) The label on the immediate packaging of glues based on cyanoacrylates shall bear the following inscription–

Cyanoacrylate.

Danger.

Bonds skin and eyes in seconds.

Keep out of the reach of children..

(2) Appropriate safety advice shall accompany the package.

Preparations containing isocyanates

3.  The label on the packaging of preparations containing isocyanates (whether as monomers, oligomers, prepolymers etc. or as mixtures thereof) shall bear the following inscriptions–

Contains isocyanates.

See information supplied by the manufacturer..

Certain preparations containing epoxy constituents

4.  The label on the packaging of preparations containing epoxy constituents with an average molecular weight ≤700 shall bear the following inscription–

Contains epoxy constituents.

See information supplied by the manufacturer..

Preparations intended to be sold to the general public that contain active chlorine

5.  The label on the packaging of preparations containing more than 1% of active chlorine which are intended to be sold to the general public shall bear the following inscription–

Warning! Do not use together with other products. May release dangerous gases (chlorine)..

Preparations containing cadmium (alloys) intended to be used for brazing or soldering

6.  The label on the packaging of preparations containing cadmium (alloys) intended to be used for brazing or soldering shall bear the following inscriptions–

Warning! Contains cadmium.

Dangerous fumes are formed during use.

See information supplied by the manufacturer.

Comply with the safety instructions..

Preparations containing substances not yet tested completely

7.  Where a preparation contains at least one substance which, in accordance with regulation 6(7) of the Notification of New Substances Regulations 1993(12), bears the inscription “Caution – substance not yet fully tested”, the label on the packaging of the preparation must bear the inscription “Warning – this preparation contains a substance not yet tested completely” if that substance is present in a concentration ≥1%.

Preparations not classified as sensitising but containing at least one sensitising substance

8.  The label on the packaging of preparations containing at least one substance classified as sensitising and being present in a concentration ≥0.1% or in a concentration greater than or equal to that specified under a specific note for the substance in the approved supply list must bear the inscription–

Contains (name of sensitising substance). May produce an allergic reaction..

Liquid preparations containing halogenated hydrocarbons

9.  For liquid preparations which show no flashpoint or a flashpoint higher than 55°C and contain a halogenated hydrocarbon and more than 5% flammable or highly flammable substances, the label on the packaging must bear the following inscription as appropriate–

Can become highly flammable in use. or

Can become flammable in use..

Preparations containing a substance assigned the risk phrase R67

10.  When a preparation contains one or more substances assigned the risk phrase R67, the label on the packaging of the preparation must bear the following inscription–

Vapours may cause drowsiness and dizziness,

when the total concentration of such substances present in the preparation is ≥15%, unless:

  • the preparation is already classified with phrases R20, R23, R26, R68/20, R39/23 or R39/26, or

  • the preparation is in a package not exceeding 125 ml.

Cement and cement preparations

11.(1) The label on the packaging of any cement or cement preparation which would contain, when hydrated, more than 0.0002% soluble chromium (VI) of the total dry weight of the cement but for the use of reducing agents shall be marked with information on the packing date, and on the storage conditions and the storage period appropriate to maintaining the activity of the reducing agent and to preventing the content of soluble chromium (VI) from exceeding 0.0002% of the total dry weight of the cement, unless it is supplied or used for controlled, closed and totally automated processes in which cement and cement-containing preparations are handled solely by machines and in which there is no possibility of contact with the skin.

(2) The label on the packaging of any cement or cement preparation containing more than 0.0002% soluble chromium (VI) of the total dry weight of the cement shall bear the inscription:

Contains chromium (VI). May produce an allergic reaction.

unless the preparation is already classified and labelled as a sensitiser with phrase R43.

CSPECIAL PROVISIONS APPLYING TO CERTAIN OTHER PREPARATIONS

Preparations not intended for the general public

12.  The label on the packaging of a preparation of the type specified in regulation 5(3) must bear the following inscription—

Safety data sheet available for professional user on request..

EXPLANATORY NOTE

(This note is not part of the Regulations)

1.  Regulations 3 and 6 of these Regulations correct certain errors in the Chemicals (Hazard Information and Packaging for Supply) Regulations 2002 (S.I. 2002/1689, as amended in particular by S.I. 2004/568, S.I. 2004/3386, S.I. 2005/2092, S.I. 2005/2571 and S.I. 2008/960) (“the principal Regulations”) in transposing provisions of—

(a)Council Directive 1992/32/EEC (OJ No. L154, 5.6.92, p.1) amending for the seventh time Council Directive 67/548/EEC (OJ No. L196, 16.8.67, p.1) on the approximation of the laws, regulations and administrative provisions relating to the classification, packaging and labelling of dangerous substances (“the substances Directive”); and

(b)Council Directive 1999/45/EC (OJ No. L200, 30.7.99, p.1) on the classification, packaging and labelling of dangerous preparations (“the preparations Directive”), concerning the labelling of single receptacles and receptacles in outer packagings where the national and international transport rules also apply. Regulation 3 corrects a cross-reference in regulation 9(2) of the principal regulations. Regulation 6 revokes amendments to the principal regulations that were made in error, as they duplicate amendments already made in an earlier instrument.

2.  Regulations 4 and 5 amend the principal Regulations in accordance with the provisions of Commission Directive 2006/8/EC (OJ No. L19, 24.1.2006 p.12) amending, for the purposes of their adaptation to technical progress, Annexes II, III and V to the preparations Directive.

3.  Regulation 7 amends the Control of Major Accident Hazards Regulations 1999 (S.I. 1999/743, as amended by S.I. 2008/960) to provide for the Health and Safety Executive to be the enforcing authority except in the circumstance provided for.

4.  A copy of the regulatory impact assessment prepared in respect of these Regulations can be obtained from the Health and Safety Executive, Economic Advisers Unit, Rose Court, 2 Southwark Bridge, London SE1 9HS. A copy of this document has been placed in the library of each House of Parliament.

(4)

Section 15(4)(a) is amended by S.I. 2008/960.

(5)

1974 c. 37, as amended by S.I. 2008/960. Section 1(1)(c) was modified by the Health and Safety at Work etc. Act (Application to Environmentally Hazardous Substances) Regulations 2002, S.I. 2002/282. There are other amending instruments but none is relevant.

(6)

Section 11(3) is substituted by S.I. 2008/960.

(7)

S.I. 2002/1689, amended by S.I. 2004/568, S.I. 2004/3386, S.I. 2005/2092, S.I. 2005/2571 and S.I. 2008/960. There are other amending instruments but none is relevant.

(8)

ISBN 0717623696.

(9)

ISBN 0717661385.

(11)

S.I. 1999/743 as amended by S.I. 2008/960, there are other amending instruments but none is relevant.

Back to top

Options/Help

Print Options

Close

Legislation is available in different versions:

Latest Available (revised):The latest available updated version of the legislation incorporating changes made by subsequent legislation and applied by our editorial team. Changes we have not yet applied to the text, can be found in the ‘Changes to Legislation’ area.

Original (As Enacted or Made): The original version of the legislation as it stood when it was enacted or made. No changes have been applied to the text.

Close

Opening Options

Different options to open legislation in order to view more content on screen at once

Close

Explanatory Memorandum

Explanatory Memorandum sets out a brief statement of the purpose of a Statutory Instrument and provides information about its policy objective and policy implications. They aim to make the Statutory Instrument accessible to readers who are not legally qualified and accompany any Statutory Instrument or Draft Statutory Instrument laid before Parliament from June 2004 onwards.

Close

More Resources

Access essential accompanying documents and information for this legislation item from this tab. Dependent on the legislation item being viewed this may include:

  • the original print PDF of the as enacted version that was used for the print copy
  • lists of changes made by and/or affecting this legislation item
  • confers power and blanket amendment details
  • all formats of all associated documents
  • correction slips
  • links to related legislation and further information resources
Close

More Resources

Use this menu to access essential accompanying documents and information for this legislation item. Dependent on the legislation item being viewed this may include:

  • the original print PDF of the as made version that was used for the print copy
  • correction slips

Click 'View More' or select 'More Resources' tab for additional information including:

  • lists of changes made by and/or affecting this legislation item
  • confers power and blanket amendment details
  • all formats of all associated documents
  • links to related legislation and further information resources