xmlns:atom="http://www.w3.org/2005/Atom"

Statutory Instruments

2002 No. 1689

HEALTH AND SAFETY

The Chemicals (Hazard Information and Packaging for Supply) Regulations 2002

Made

28th June 2002

Laid before Parliament

3rd July 2002

Coming into force

24th July 2002

The Secretary of State being the Minister designated(1) for the purpose of section 2(2) of the European Communities Act 1972(2) in relation to the regulation and control of classification, packaging and labelling of dangerous substances and preparations, and for measures relating to consumer protection, in the exercise of the powers conferred on him by the said section 2(2)(3) and by sections 15(1), (2), (3)(c), (5)(b), (6)(b), (8) and (9) and 82(3)(a) of, and paragraphs 1(1)(b) and (c), (4) and (5), 2(1), 3(2), 15(1) and 16 of Schedule 3 to, the Health and Safety at Work etc. Act 1974(4) (“the 1974 Act”) and of all other powers enabling him in that behalf and for the purpose of giving effect without modifications to proposals submitted to him by the Health and Safety Commission under section 11(2)(d) of the 1974 Act after the carrying out by the said Commission of consultations in accordance with section 50(3) of that Act, hereby makes the following Regulations:

PART IPRELIMINARY

Citation, commencement and extent

1.—(1) These Regulations may be cited as the Chemicals (Hazard Information and Packaging for Supply) Regulations 2002 and shall come into force on 24th July 2002.

(2) These Regulations shall not extend to Northern Ireland.

Interpretation

2.—(1) In these Regulations,—

“the 1974 Act” means the Health and Safety at Work etc. Act 1974;

“aerosol dispenser” means an article which consists of a non-reusable receptacle containing a gas compressed, liquefied or dissolved under pressure, with or without liquid, paste or powder and fitted with a release device allowing the contents to be ejected as solid or liquid particles in suspension in a gas, as a foam, paste or powder or in a liquid state;

“the approved classification and labelling guide” means the guide entitled “Approved Guide to the Classification and Labelling of Dangerous Substances and Dangerous Preparations (Fifth Edition)” approved by the Health and Safety Commission on 16th April 2002;

“the approved supply list” means the document entitled “Information Approved for the Classification and Labelling of Dangerous Substances and Dangerous Preparations (Seventh Edition)” approved by the Health and Safety Commission on 16th April 2002;

“category of danger” means, in relation to a dangerous substance or dangerous preparation, one of the categories of danger specified in column 1 of Schedule 1;

“the CDGCPL Regulations” means the Carriage of Dangerous Goods (Classification, Packaging and Labelling) and Use of Transportable Pressure Receptacles Regulations 1996(5);

“Community workplace exposure limit” means, in respect of a substance, an exposure limit for that substance established in a Community instrument;

“dangerous preparation” means a preparation which is in one of or more of the categories of danger specified in column 1 of Schedule 1;

“dangerous substance” means a substance—

(a)

which is listed in the approved supply list; or

(b)

if it is not so listed, which is in one or more of the categories of danger specified in column 1 of Schedule 1;

“EC number” means—

(a)

in the case of a dangerous substance that appears in the approved supply list, the EC number specified in that list;

(b)

in the case of a dangerous substance that is not included in the approved supply list or for which an EC number is not given in that list, the number for that substance specified in EINECS; or

(c)

in the case of a dangerous substance that is a new substance within the meaning of the NONS Regulations, the number for that substance listed in ELINCS;

“EEA Agreement” means the Agreement on the European Economic Area signed at Oporto on 2nd May 1992, as adjusted by the Protocol signed at Brussels on 17th March 1993(6) and adopted as respects the United Kingdom by the European Economic Area Act 1993(7);

“EEA State” means a state which is a contracting party to the EEA Agreement;

“EINECS” means the European Inventory of Existing Commercial Chemical Substances(8);

“ELINCS” means the European List of Notified Chemical Substances(9) as revised or re-issued from time to time;

“enforcing authority” shall be construed in accordance with regulation 14;

“the Executive” means the Health and Safety Executive;

“indication of danger” means, in relation to a dangerous substance or dangerous preparation, one or more of the indications of danger referred to in column 1 of Schedule 2 and—

(a)

in the case of a dangerous substance listed in the approved supply list, it is one or more of the indications of danger specified for that substance by a symbol-letter in that list;

(b)

in the case of any other dangerous substance or a dangerous preparation, it is one or more indications of danger determined in accordance with the classification of that substance or preparation in accordance with regulation 4 and the approved classification and labelling guide;

“the NONS Regulations” means the Notification of New Substances Regulations 1993(10);

“plant protection product” has the same meaning as it has in regulation 2(1) of the Plant Protection Products Regulations;

“the Plant Protection Products Regulations” means the Plant Protection Products Regulations 1995(11);

“preparation” means a mixture or a solution of two or more substances;

“radioactive substance” means a substance which contains one or more radionuclides whose activity or concentration cannot be disregarded as far as radiation protection is concerned;

“receptacle” means a container together with any material, wrapping and component, including any closure or fastener, associated with the container which enables the container to perform its containment function;

“risk phrase” means a risk phrase listed in the approved supply list;

“safety phrase” means a safety phrase listed in the approved supply list;

“substance” means a chemical element and its compounds in the natural state or obtained by any production process, including any additive necessary to preserve the stability of the product and any impurity deriving from the process used, but excluding any solvent which may be separated without affecting the stability of the substance or changing its composition;

“supply” in relation to a substance or preparation means, except in regulation 6, making that substance or preparation available to another person and includes importation of the substance or preparation into Great Britain, and “supplier” shall be construed accordingly.

(2) In these Regulations, “package” means—

(a)subject to paragraph (3), the package in which a dangerous substance, dangerous preparation or preparation specified in regulation 5(3) is supplied, including the receptacle containing the dangerous substance or preparation in question; or

(b)a pallet or other device which enables more than one receptacle to be handled as a unit,

but does not include a container used to transport the dangerous substance or preparation unless that container is retained by the person to whom the dangerous substance or preparation is supplied for the purpose of storing that dangerous substance or preparation, and related expressions shall be construed accordingly.

(3) In the case of supply by way of retail sale, a package does not include any paper or plastic bag or other form of outer wrapping in which the package is placed when it is presented to the purchaser.

(4) In these Regulations—

(a)where reference is made to a quantity of a dangerous substance or dangerous preparation expressed in litres, that reference shall mean—

(i)in the case of a liquid, the volume in litres of that liquid,

(ii)in the case of a compressed gas, the volume in litres of the receptacle containing that gas, and

(iii)in the case of a compressed gas dissolved in a solvent, liquefied gas or solid, the same number of kilograms of that gas or solid; and

(b)for the purposes of aggregation, one kilogram of a solid shall be deemed to be equivalent to one litre of liquid or gas.

(5) In these Regulations—

(a)a risk phrase may be designated by the letter “R” followed by a distinguishing number or combination of numbers; and

(b)a safety phrase may be designated by the letter “S” followed by a distinguishing number or combination of numbers.

(6) In these Regulations, unless the context otherwise requires, a reference to—

(a)a numbered regulation or Schedule is a reference to the regulation or Schedule in these Regulations so numbered;

(b)a numbered paragraph is a reference to the paragraph so numbered in the regulation or Schedule in which that reference occurs; and

(c)a lettered sub-paragraph is a reference to the sub-paragraph so lettered in the paragraph in which that reference appears.

Application

3.—(1) Subject to paragraphs (3) to (8), these Regulations shall apply to any dangerous substance or dangerous preparation.

(2) Subject to paragraphs (3) to (8)—

(a)regulation 5, except paragraph (1), shall apply to the preparations specified in paragraph (3) of that regulation;

(b)regulation 7 and paragraphs (2) and (4) to (6) of regulation 11 shall apply to the preparations specified in paragraph (3) of regulation 11;

(c)paragraphs (1) and (2) of regulation 9 shall apply to a preparation to which section B or C of Part II of Schedule 5 applies; and

(d)paragraphs (4) and (5) of regulation 8 shall apply to a substance or preparation specified in those paragraphs.

(3) These Regulations shall not apply to a substance or preparation which is—

(a)intended for use as a medicinal product within the meaning of section 130 of the Medicines Act 1968(12);

(b)specified in an order made under section 104 or 105 of the Medicines Act 1968 which is for the time being in force and which directs that specified provisions of that Act shall have effect in relation to that dangerous substance or dangerous preparation as such provisions have effect in relation to medicinal products within the meaning of that Act;

(c)a controlled drug within the meaning of the Misuse of Drugs Act 1971(13) except that these Regulations shall apply to drugs which are excepted from section 4(1)(b) of that Act (which makes it unlawful to supply a controlled drug) by Regulations made under section 7(1)(a) of that Act;

(d)a cosmetic product within the meaning of the Cosmetic Products (Safety) Regulations 1996(14);

(e)in the form of waste to which the Waste Management Licensing Regulations 1994(15) or the Special Waste Regulations 1996(16) applies;

(f)intended for use as food within the meaning of section 1 of the Food Safety Act 1990(17);

(g)intended for use as an animal feeding stuff within the meaning of section 66(1) of the Agriculture Act 1970(18);

(h)radioactive substances or preparations containing radioactive substances; or

(i)a medical device within the meaning of the Medical Devices Regulations 2002(19) which is invasive or used in direct contact with the human body,

in the finished state, intended for the final user.

(4) These Regulations shall not apply to—

(a)a substance or preparation which is a sample taken by an authority responsible for the enforcement of any requirement imposed by or under any enactment;

(b)a substance or preparation which is under customs control;

(c)subject to Council Regulation EC 2455/92(20) on the export notification and information exchange of dangerous substances, a substance or preparation which is intended for export to a country which is not an EEA State; or

(d)a substance to which paragraph (7) of regulation 6 of the NONS Regulations applies (including new substances not yet fully tested) which is labelled in accordance with the provisions of that paragraph;

(5) Regulations 7 to 11 shall only apply to dangerous substances, dangerous preparations or preparations specified in regulation 5(3) which are supplied in packages.

(6) Regulations 7 to 11 shall not apply to munitions and explosives which are placed on the market with a view to obtaining an explosive or pyrotechnic effect.

(7) Regulation 6 shall not apply to a plant protection product approved under the Plant Protection Products Regulations or to a product approved under the Control of Pesticides Regulations 1986(21).

(8) These Regulations shall not apply to the carriage of substances or preparations by rail, road, inland waterway, sea or air.

PART IIGENERAL REQUIREMENTS

Classification of dangerous substances and dangerous preparations

4.—(1) No person shall supply a dangerous substance or a dangerous preparation unless it has been classified in accordance with paragraphs (2) to (7).

(2) The classification of a dangerous substance which is listed in the approved supply list shall be the classification for that substance specified in that list.

(3) A dangerous substance which—

(a)is a new substance not listed in the approved supply list; and

(b)has been notified in accordance with regulation 4 or 6(1) or (2) of the NONS Regulations,

shall be classified in conformity with that notification.

(4) Subject to paragraph (5), a dangerous substance which is not classified in accordance with paragraph (2) or (3) shall be classified—

(a)by ascertaining which of the properties specified in Column 2 of Schedule 1 applies to the dangerous substance and by placing the dangerous substance in one or more of the categories of danger specified in the corresponding entry in Column 1 of that part;

(b)by assigning to the dangerous substance the appropriate risk phrases by the use of the criteria set out in the approved classification and labelling guide; and

(c)where it is proposed to classify a dangerous substance in the category of danger carcinogenic, mutagenic or toxic for reproduction, by an assessment of the evidence by a competent person.

(5) Before a dangerous substance is classified in accordance with paragraph (4), the person carrying out the classification shall make himself aware of all relevant and accessible data which may exist in relation to the dangerous substance in question.

(6) Where a manufacturer, distributor or importer has classified a substance, in accordance with the provisions of paragraph (4), as a dangerous substance in the category of danger carcinogenic, mutagenic or toxic for reproduction, that person shall send to the Executive as soon as possible a document—

(a)summarising the information on which the classification was based; and

(b)including all relevant references and unpublished data,

unless that document has already been sent to the relevant authority in another EEA State in which the dangerous substance has been supplied.

(7) A dangerous preparation shall be classified in accordance with Schedule 3 and, where applicable, by use of the criteria contained in the approved classification and labelling guide.

Safety data sheets for dangerous substances, dangerous preparations and certain other preparations

5.—(1) Subject to paragraph (7), the supplier of a dangerous substance or dangerous preparation shall provide the recipient of that dangerous substance or dangerous preparation with a safety data sheet—

(a)which contains the information under the headings specified in Schedule 4 to enable that recipient to take the necessary measures relating to—

(i)health and safety at work, and

(ii)the protection of the environment;

(b)which clearly shows the date of first publication, or the latest revision, as the case may be;

(c)free of charge; and

(d)no later than the date on which the dangerous substance or the dangerous preparation is supplied to that recipient for the first time.

(2) Subject to paragraph (7), the supplier of a preparation of the type specified in paragraph (3) shall provide free of charge to a professional user a safety data sheet which—

(a)contains proportionate information under the headings specified in Schedule 4 relating to that preparation; and

(b)clearly shows the date of first publication, or the latest revision, as the case may be,

when requested to do so by that professional user.

(3) Paragraph (2) refers to a preparation which is not a dangerous preparation but which contains in an individual concentration of ≥1% by weight for non-gaseous preparations and ≥0.2% by volume for gaseous preparations—

(a)a dangerous substance which has been classified in respect of its health or environmental effects; or

(b)a substance for which there is a Community workplace exposure limit.

(4) The supplier of a dangerous substance or preparation to which this regulation applies shall keep the safety data sheet relating to that dangerous substance or preparation up to date and revise it forthwith if any significant new information relating to safety at work, risks to the health of any person or the protection of the environment becomes available in relation to that dangerous substance or preparation.

(5) When a supplier revises a safety data sheet in accordance with paragraph (4), he shall ensure that the safety data sheet is clearly marked with the word “Revision”.

(6) When a supplier revises a safety data sheet in accordance with paragraph (4), he shall—

(a)in respect of a dangerous substance or dangerous preparation, provide every person who has received that dangerous substance or dangerous preparation within a period of 12 months preceding the date of the revision with a copy of the revised safety data sheet free of charge; or

(b)in respect of a preparation specified in paragraph (3), provide every person who—

(i)has received that preparation within a period of 12 months preceding the date of the revision, and

(ii)requested a copy of the safety data sheet in accordance with paragraph (2),

with a copy of the revised safety data sheet free of charge, and shall draw the attention of every such person to the revisions in the safety data sheet.

(7) Subject to paragraph (8), a supplier shall not be required to provide a safety data sheet with a dangerous substance or preparation to which this regulation applies provided that—

(a)the dangerous substance or preparation is sold to the general public in the circumstances to which paragraph (4) or (5) of regulation 14 applies; and

(b)sufficient information is provided to enable the user of that dangerous substance or preparation to take the necessary measures as regards the protection of health and safety.

(8) Where a person buys a dangerous substance or preparation to which this regulation applies for use at work in the circumstances to which paragraph (4) or (5) of regulation 14 applies, when requested to do so by that person, the supplier of the dangerous substance or preparation in question shall provide that person with a copy of the safety data sheet relating to that dangerous substance or preparation free of charge.

(9) If a supplier provides a safety data sheet in accordance with paragraph (8), paragraph (6) shall not apply.

(10) The information contained in a safety data sheet provided under this regulation shall be in English.

(11) A supplier may provide a safety data sheet or a revision to a safety data sheet under this regulation by electronic communication provided that he has established that the person to whom the safety data sheet, or the revision to a safety data sheet, will be provided has the equipment to enable him to receive the electronic communication.

(12) In this regulation, “supply” shall not include supply by way of—

(a)offer for sale, and

(b)returning a dangerous substance or preparation to which this regulation applies to the person who supplied it, provided that the properties of that dangerous substance or preparation remain unchanged,

and “supplier” shall be construed accordingly.

Advertisements for dangerous substances and dangerous preparations

6.—(1) Subject to paragraph (2), a person who supplies a dangerous substance or dangerous preparation shall not advertise that dangerous substance or dangerous preparation, or arrange for the production of any such advertisement, unless mention is made in the advertisement of the type of hazard indicated on the label.

(2) Paragraph (1) shall only apply in respect of a dangerous preparation where the advertisement enables a person, otherwise than in the course of a business, to conclude a contract to purchase the dangerous preparation before that person has seen the label relating to the dangerous preparation.

(3) In this regulation “supply” has the same meaning as it has in section 46 of the Consumer Protection Act 1987(22).

Packaging of dangerous substances and dangerous preparations

7.—(1) No person shall supply a dangerous substance, dangerous preparation or preparation specified in regulation 11(3) unless it is in a package and—

(a)subject to paragraph (2), the receptacle containing the dangerous substance or dangerous preparation is designed and constructed so that its contents cannot escape;

(b)the materials constituting the packaging and fastenings are not susceptible to adverse attack by the contents or liable to form dangerous compounds with the contents;

(c)the packaging and fastenings are strong and solid throughout to ensure that they will not loosen and will meet the normal stresses and strains of handling; and

(d)any replaceable fastening fitted to the receptacle containing the dangerous substance or dangerous preparation is designed so that the receptacle can be repeatedly refastened without the contents of the receptacle escaping.

(2) Paragraph (1)(a) shall not apply where a special safety device is fitted to the receptacle.

(3) Packaging and fastenings shall be deemed to comply with the requirements of paragraph (1)(a) to (c) if they comply with the relevant requirements of—

(a)the CDGCPL Regulations;

(b)the Merchant Shipping (Dangerous Goods and Marine Pollutants) Regulations 1997(23); or

(c)the Air Navigation (Dangerous Goods) Regulations 1994(24).

Labelling of dangerous substances and dangerous preparations

8.—(1) Subject to regulations 9 and 10 of the CDGCPL Regulations (which allow combined carriage and supply labelling in certain circumstances) and paragraphs (8) to (12), no person shall supply a dangerous substance or dangerous preparation unless the particulars specified in paragraph (2) relating to a dangerous substance or paragraph (3) relating to a dangerous preparation are clearly shown in accordance with the requirements of regulation 10—

(a)on the receptacle containing the dangerous substance or dangerous preparation; and

(b)if that receptacle is inside one or more layers of packaging, on any such layer which is likely to be the outermost layer of packaging during the supply or use of the dangerous substance or dangerous preparation, unless such packaging permits the particulars shown on the receptacle or other packaging to be clearly seen.

(2) The particulars required under paragraph (1) in relation to a dangerous substance shall be—

(a)the name, full address and telephone number of a person in an EEA State who is responsible for supplying the substance, whether he be its manufacturer, importer or distributor;

(b)the name of the substance, being—

(i)where the substance appears in the approved supply list, the name or one of the names listed therein for that substance, or

(ii)where the substance does not appear in the approved supply list, an internationally recognised name;

(c)the following particulars ascertained in accordance with Part I of Schedule 5, namely—

(i)any indications of danger together with corresponding symbols,

(ii)the risk phrases, set out in full,

(iii)the safety phrases, set out in full, and

(iv)any EC number and, in the case of a substance which is listed in Part I of the approved supply list, the words “EC label”; and

(d)where required by paragraph (4) or (5), the labelling phrase specified therein.

(3) The particulars required under paragraph (1) in relation to a dangerous preparation shall be—

(a)the name, full address and telephone number of a person in an EEA State who is responsible for supplying the preparation, whether he be its manufacturer, importer or distributor;

(b)the trade name or other designation of the preparation;

(c)the following particulars ascertained in accordance with Part I of Schedule 5, namely—

(i)identification of the constituents of the preparation which result in it being classified as a dangerous preparation,

(ii)any indications of danger together with corresponding symbols,

(iii)the risk phrases, set out in full,

(iv)the safety phrases, set out in full,

(v)in the case of a preparation intended for sale to the general public, the nominal quantity (nominal mass or nominal volume);

(d)where required by paragraph 5(4) of Part I of Schedule 3, the words specified in that paragraph; and

(e)where required by paragraph (4) or (5), the labelling phrase specified therein.

(4) Subject to paragraph (6), and without prejudice to any other requirements in these Regulations, in respect of a substance specified in Schedule 2 to the Dangerous Substances and Preparations (Safety) (Consolidation) Regulations 1994(25) or a preparation containing such a substance, either of which is required to be classified and labelled in accordance with these Regulations, as—

(a)carcinogenic of category 1 or 2;

(b)mutagenic of category 1 or 2; or

(c)toxic for reproduction of category 1 or 2,

the labelling phrase “Restricted to professional users” shall be included in the particulars specified in paragraph (2) or (3), as the case may be.

(5) Without prejudice to any other requirements in these Regulations, in respect of—

(a)a substance specified in regulation 6D of the Dangerous Substances and Preparations (Safety) (Consolidation) Regulations 1994; or

(b)a preparation containing such a substance in a concentration by weight of 0.1% or more,

whether or not that substance is a dangerous substance or that preparation is a dangerous preparation, as the case may be, the labelling phrase “For use in industrial installations only” shall be included in the particulars specified in paragraph (2) or (3), as the case may be.

(6) Paragraph 4 shall not apply to—

(a)petrol as defined in regulation 2 of the Motor Fuel (Composition and Content) Regulations 1999(26);

(b)mineral oil products intended for use as fuel in mobile or fixed combustion plants;

(c)fuels sold in closed systems; and

(d)artists' paints.

(7) Without prejudice to paragraph 4 of Schedule 2 to the Plant Protection Products Regulations, indications such as “non-toxic”, “non-harmful”, “non-polluting”, “ecological” or any other statement indicating that the dangerous substance or preparation is not dangerous or that is likely to lead to underestimation of the dangers of the dangerous substance or preparation shall not appear on the package.

(8) Where paragraph (9) applies, the packaging of a dangerous substance or dangerous preparation classified in one or more of the categories of danger harmful, extremely flammable, highly flammable, flammable, irritant or oxidising shall not be required to be labelled in respect of that hazardous property.

(9) This paragraph shall apply where the package contains such small quantities of that substance or preparation that there is no foreseeable risk, under conditions of supply, use and disposal, arising from that hazardous property to persons handling that substance or preparation or to other persons.

(10) The packaging of a dangerous preparation classified in the category of danger dangerous for the environment (with or without the “N” symbol) shall not be required to be labelled in respect of its environmental hazard in accordance with this regulation provided that it contains such small quantities of that preparation that there is no foreseeable risk, under conditions of supply, use and disposal, to the environment.

(11) Where the package in which a dangerous substance is supplied does not contain more than 125 millilitres of that substance the risk phrases and safety phrases need not be shown if the dangerous substance is classified only in one or more of the categories of danger—

(a)highly flammable, flammable, oxidising or irritant; or

(b)harmful, provided the dangerous substance is not sold to the general public.

(12) Where the package in which a dangerous preparation is supplied does not contain more than 125 millitres of that preparation—

(a)the risk phrases and safety phrases need not be shown if the dangerous preparation is classified only in one or more of the categories of danger—

(i)irritant (except those assigned the risk phrase R41),

(ii)dangerous for the environment and assigned the N symbol,

(iii)oxidising, or

(iv)highly flammable; and

(b)the safety phrases need not be shown if the dangerous preparation is classified only in one or more of the categories of danger—

(i)flammable, or

(ii)dangerous for the environment and not assigned the N symbol.

(13) Where a dangerous substance or dangerous preparation is required to be labelled in accordance with these Regulations and is so labelled, that labelling shall be deemed to satisfy the requirements of—

(a)section 5 of the Petroleum (Consolidation) Act 1928(27) including that section as applied to any dangerous substance by an Order in Council made under section 19 of that Act;

(b)regulation 6 of the Highly Flammable Liquids and Liquefied Petroleum Gases Regulations 1972(28); and

(c)regulations 3 and 4 of the Farm and Garden Chemicals Regulations 1971(29).

Particular labelling requirements for certain preparations

9.—(1) In the case of preparations to which Part II of Schedule 5 applies the appropriate provisions of that Part shall have effect to regulate the labelling of such preparations.

(2) Subject to regulations 9 and 10 of the CDGCPL Regulations (which allow combined carriage and supply labelling in certain circumstances), no person shall supply a preparation to which section B or C of Part II of Schedule 5 applies unless the trade name or other designation of that preparation and the name, full address and telephone number of a person in an EEA State who is responsible for supplying that preparation (whether he be its manufacturer, importer or distributor) are clearly shown in accordance with the requirements of regulation 10—

(a)on the receptacle containing that preparation; and

(b)if that receptacle is inside one or more layers of packaging, on any such layer which is likely to be the outermost layer of packaging during the supply or use of that preparation, unless such packaging permits the particulars shown on the receptacle or other packaging to be clearly seen.

(3) The supplier of an aerosol dispenser which contains a dangerous substance or dangerous preparation which has been classified in the category of danger “flammable”, “highly flammable” or “extremely flammable” may choose to omit from the label—

(a)in the case of a dangerous substance, the particulars referred to in paragraphs (i) to (iii) of regulation 8(2)(c) which relate to that category of danger; and

(b)in the case of a dangerous preparation, the particulars referred to in paragraphs (ii) to (iv) of regulation 8(3)(c) which relate to that category of danger,

provided the conditions specified in paragraph (4) are satisfied.

(4) The conditions referred to in paragraph (3) are that the supplier—

(a)is in possession of evidence which shows that the contents of the aerosol dispenser do not present a risk of ignition under normal or reasonably foreseeable conditions of use; and

(b)identifies the quantity of flammable material contained in the aerosol dispenser in the form of the following inscription on the label—

(5) In the case of a plant protection product approved under the Plant Protection Products Regulations or a product approved under the Control of Pesticides Regulations 1986(30), the labelling information required by these Regulations shall be accompanied by the wording “To avoid risks to man and the environment, comply with the instructions for use”.

Methods of marking or labelling packages

10.—(1) Any package which is required to be labelled in accordance with regulations 8 and 9 may carry the particulars required to be on the label clearly and indelibly marked on a part of that package reserved for that purpose and, unless the context otherwise requires, any reference in these Regulations to a label includes a reference to that part of the package so reserved.

(2) Subject to paragraph (7), any label required to be carried on a package shall be securely fixed to the package with its entire surface in contact with it and the label shall be clearly and indelibly printed.

(3) The colour and nature of the marking shall be such that any symbol and the wording stand out clearly from the background and the wording shall be of such size and spacing as to be easily read.

(4) The package shall be so labelled that the particulars can be read horizontally when the package is set down normally.

(5) Subject to paragraph (7), the dimensions of the label required under regulation 8 shall be as follows—

Capacity of packageDimensions of label
(a)not exceeding 3 litresif possible at least 52 × 74 millimetres
(b)exceeding 3 litres but not exceeding 50 litresat least 74 × 105 millimetres
(c)exceeding 50 litres but not exceeding 500 litresat least 105 × 148 millimetres
(d)exceeding 500 litresat least 148 × 210 millimetres

(6) A symbol required to be shown in accordance with regulation 8(2)(c)(i) or 8(3)(c)(ii) and specified in column 3 of Schedule 2 shall be printed in black on an orange-yellow background and its size (including the orange-yellow background) shall be at least equal to an area of one-tenth of that of a label which complies with paragraph (5) and shall not in any case be less than 100 square millimetres.

(7) If the package is an awkward shape or so small that it is unsuitable to attach a label complying with paragraphs (2) and (5), the label shall be attached in some other appropriate manner.

Child resistant fastenings, tactile warning devices and other consumer protection measures

11.—(1) The British and International Standards referred to in this regulation are further described in Schedule 6.

(2) Subject to paragraph (4) and (5), no person shall supply to the general public a substance or a preparation specified in paragraph (3) in a receptacle of any size fitted with—

(a)a replaceable closure unless the packaging complies with the requirements of BS EN 28317 or ISO 8317; or

(b)a non-replaceable closure unless the packaging complies with the requirements of EN 862.

(3) The substances and preparations referred to in paragraph (2) are—

(a)dangerous substances and dangerous preparations which are required to be labelled with the indication of danger “very toxic”, “toxic” or “corrosive”;

(b)preparations containing methanol in a concentration equal to or more than 3% by weight;

(c)preparations containing dichloromethane in a concentration equal to or more than 1% by weight;

(d)substances which are assigned the risk phrase (R65) in the approved supply list, except where such a substance is supplied in an aerosol dispenser or a container fitted with a sealed spray attachment; and

(e)substances and preparations which are assigned the risk phrase (R65) and are classified and labelled according to the approved classification and labelling guide, except where such a substance or preparation is supplied in an aerosol dispenser or a container fitted with a sealed spray attachment.

(4) Paragraph (2) shall not apply if the person supplying the substance or preparation in question can show that it is obvious that the packaging in which the substance or preparation is supplied is sufficiently safe for children because they cannot obtain access to the contents without the help of a tool.

(5) If the packaging, in which a substance or preparation specified in paragraph (3) is supplied to the general public, was approved on or before 31st May 1993 by the British Standards Institution as complying with the requirements of BS 6652, that packaging shall be deemed to comply with the requirements of BS EN 28317.

(6) No person shall supply a dangerous preparation or a preparation specified in paragraph (3) to the general public if the packaging in which that preparation is supplied has—

(a)either a shape or a designation or both likely to attract or arouse the active curiosity of children or to mislead consumers;

(b)either a presentation or a designation or both used for—

(i)human or animal foodstuffs,

(ii)medicinal products, or

(iii)cosmetic products.

(7) Subject to paragraph (9), no person shall supply to the general public a dangerous substance or a dangerous preparation specified in paragraph (8) in a receptacle of any size, unless the packaging in which that dangerous substance or dangerous preparation is supplied carries a tactile warning of danger in accordance with EN ISO 11683.

(8) The dangerous substances and the dangerous preparations referred to in paragraph (7) are those which are required to be labelled with one or more of the following indications of danger, namely—

(a)very toxic;

(b)toxic;

(c)corrosive;

(d)harmful;

(e)extremely flammable; or

(f)highly flammable.

(9) Paragraph (7) shall not apply to an aerosol dispenser which is classified and labelled only with the indication of danger extremely flammable or highly flammable.

(10) For the purpose of ascertaining whether there has been a contravention of paragraph (2), a duly authorised officer of the enforcing authority may require the person supplying a substance or a preparation to which that paragraph applies to provide him with a certificate from a qualified test house stating that—

(a)the closure is such that it is not necessary to test to BS EN 28317 or ISO 8317; or

(b)the closure has been tested and found to conform to BS EN 28317 or ISO 8317.

(11) In this regulation, “qualified test house” means a laboratory that conforms to BS 7501 or EN 45 000.

Retention of data for dangerous preparations

12.—(1) The person who is responsible for first supplying a dangerous preparation shall maintain a record of the information—

(a)used for the purposes of classifying that dangerous preparation in accordance with regulation 4;

(b)used for the purposes of labelling that dangerous preparation in accordance with regulation 8;

(c)relating to any child resistant fastening or any tactile warning which forms part of the packaging in which the dangerous preparation in question is contained; and

(d)used for the purposes of preparing the safety data sheet relating to that dangerous preparation in accordance with regulation 5,

for at least three years after the date on which that dangerous preparation was supplied by him for the last time.

(2) When requested by the enforcing authority to do so, a person referred to in paragraph (1) shall make the record, or a copy of the record, maintained by him in accordance with that paragraph, available to the enforcing authority within 28 days of the date of the request.

(3) When requested to do so by the enforcing authority, a person who supplies a dangerous preparation shall provide to the enforcing authority a copy of any certificate issued by a qualified test house.

PART IIIMISCELLANEOUS

Exemption certificates

13.—(1) Subject to paragraph (2), the Executive may by a certificate in writing exempt—

(a)any person or class of persons;

(b)any substance or preparation; or

(c)any class of such substances or preparations,

from all or any of the requirements of, or prohibitions imposed by, these Regulations.

(2) An exemption granted under paragraph (1) may be granted subject to conditions and to a limit of time and may be revoked by the Executive at any time by a certificate in writing.

(3) The Executive shall not grant an exemption pursuant to paragraph (1) unless, having regard to the circumstances of the case, and in particular to—

(a)any conditions which it proposes to attach to the exemption; and

(b)any requirements imposed by or under any enactments which apply to the case,

it is satisfied that neither the health nor the safety of persons who are likely to be affected by the exemption will be prejudiced in consequence of it.

Enforcement

14.—(1) To the extent that they would not otherwise do so, sections—

(a)16 to 26 (approval of codes of practice and enforcement);

(b)33 to 42 (provisions as to offences); and

(c)47(2),

of the 1974 Act shall apply to these Regulations as if they were health and safety Regulations for the purposes of that Act.

(2) Any function of the Health and Safety Commission under any other provision of the 1974 Act which is exercisable in relation to any function of the Executive under or in respect of health and safety Regulations (including their enforcement) shall be exercisable as if these Regulations were health and safety Regulations for the purposes of that Act to the extent that they would not otherwise be so.

(3) Notwithstanding regulation 3 of the Health and Safety (Enforcing Authority) Regulations 1998(31) and subject to paragraphs (4) and (5), the enforcing authority for these Regulations shall be the Executive.

(4) Subject to paragraph (5), where a dangerous substance or a dangerous preparation is supplied in or from premises which are registered under section 75 of the Medicines Act 1968(32), the enforcing authority for these Regulations shall be the Royal Pharmaceutical Society.

(5) The enforcing authority for these Regulations shall be the local weights and measures authority—

(a)where a dangerous substance or a dangerous preparation is supplied other than in the circumstances referred to in paragraph (4),—

(i)in or from any shop, mobile vehicle, market stall or other retail outlet, or

(ii)otherwise to members of the public, including by way of free sample, prize or mail order;

(b)for regulations 6 and 11.

(6) In every case where, by virtue of this regulation, these Regulations are enforced by the Royal Pharmaceutical Society or the local weights and measures authority, they shall be enforced as if they were safety regulations made under section 11 of the Consumer Protection Act 1987(33) and the provisions of section 12 of that Act shall apply to these Regulations as if they were safety regulations and as if the maximum period of imprisonment on summary conviction specified in subsection (5) thereof were 3 months instead of 6 months.

Defence

15.—(1) In any proceedings for an offence for a contravention of any of the provisions of these Regulations, it shall be a defence for the person charged to prove that he took all reasonable precautions and exercised all due diligence to avoid the commission of the offence.

Transitional provisions

16.—(1) Until 30th July 2002 it shall be sufficient compliance with the requirements of these Regulations if the requirements of the Chemicals (Hazard Information and Packaging for Supply) Regulations 1994(34) are complied with as in force immediately before these Regulations came into force.

(2) In respect of a preparation which is a biocidal product within the meaning of the Biocidal Products Regulations 2001(35), until 30th July 2004 it shall be sufficient compliance with the requirements of these Regulations if the requirements of the Chemicals (Hazard Information and Packaging for Supply) Regulations 1994 are complied with as in force immediately before these Regulations came into force.

(3) These Regulations shall not apply to a preparation which is—

(a)an approved plant protection product under the Plant Protection Products Regulations; or

(b)an approved biocidal product under the Biocidal Products Regulations 2001,

until 30th July 2004.

(4) These Regulations shall not apply to a preparation which is—

(a)a biocidal product within the meaning of the Biocidal Products Regulations 2001; or

(b)a plant protection product,

and which is an approved product under the Control of Pesticides Regulations 1986(36) until 30th July 2004.

(5) In this regulation, “biocidal product” does not include a biocidal product which is a basic substance as defined in article 2 of Directive 98/8(37) of the European Parliament and the Council concerning the placing of biocidal products on the market.

Extension outside Great Britain

17.  These Regulations shall apply to any activity outside Great Britain to which sections 1 to 59 and 80 to 82 of the 1974 Act apply by virtue of the Health and Safety at Work etc. Act 1974 (Application outside Great Britain) Order 2001(38) as they apply to activities within Great Britain.

Revocations and modifications

18.—(1) The instruments specified in column 1 of Schedule 7 shall be revoked to the extent specified in the corresponding entry in column 3 of that Schedule.

(2) In the CDGCPL Regulations—

(a)for regulations 9 and 10 there shall be substituted the following regulations—

Derogations from regulation 8 of the supply Regulations and regulation 8 of these Regulations

9.(1) Where a package would otherwise be required to show the particulars required by both regulation 8 of the supply Regulations and regulation 8 of these Regulations, it shall be sufficient compliance with both of those regulations if the package shows in accordance with regulation 11 the particulars specified in the following paragraphs of this regulation.

(2) Where the package consists of only a single receptacle, the specified particulars are the particulars required by paragraph (2)(a), (b), (c)(ii), (iii) and (iv) (or paragraph (3)(a), (b), (c)(i), (iii), (iv) and (v) in the case of preparations) of regulation 8 of the supply Regulations and paragraph (2)(b), (c) and (d) of regulation 8 of these Regulations.

(3) Where the package consists of one or more receptacles in outer packagings, the specified particulars are either the particulars required by paragraph (2) or the particulars required by regulation 8.

(4) Where, to facilitate handling, a package consists of two or more smaller packages held together in such a way that the labels on those smaller packages can be clearly seen, then it shall be sufficient compliance with paragraph (3) if those smaller packages are labelled in accordance with that paragraph.

(5) In this regulation “preparations” and “indication of danger” have the same meaning as in the supply Regulations.

Derogations from regulation 8 of the supply Regulations

10.(1) Where a package is required to show the particulars required by regulation 8 of the supply Regulations, but is excepted from showing the particulars required by regulation 8 of these Regulations because it shows the particulars required by any of the transport rules specified in regulation 3(1)(a) to (f), it shall be sufficient compliance with regulation 8 of the supply Regulations if the package shows the particulars specified in the following paragraphs of this regulation.

(2) Where the package consists of only a single receptacle, the specified particulars are—

(a)the particulars required by whichever of the transport rules is appropriate; and

(b)the particulars required by paragraph (2)(a), (b), (c)(ii), (iii) and (iv) (or paragraph (3)(a), (b), (c)(i), (iii), (iv) and (v)) of regulation 8 of the supply Regulations in accordance with regulation 11.

(3) Where the package consists of one or more receptacles in outer packagings, the specified particulars are those required by whichever of the transport rules is appropriate.

(4) In this regulation “indication of danger” has the same meaning as in the supply Regulations.; and

(b)in paragraph (5) of regulation 11, for the words “regulation 9 of the supply Regulations” there shall be substituted “regulation 8 of the supply Regulations”.

David Jamieson

Parliamentary Under-Secretary of State,

Department for Transport

28th June 2002

Regulations 2(1) and 4(4)

SCHEDULE 1CLASSIFICATION OF DANGEROUS SUBSTANCES AND DANGEROUS PREPARATIONS

CATEGORIES OF DANGER

Column 1Column 2Column 3
Category of dangerProperty (See Note 1)Symbol-letter

Notes

1.

As further described in the approved classification and labelling guide.

2.

The categories are specified in the approved classification and labelling guide.

3.

In certain cases specified in the approved supply list and in the approved classification and labelling guide substances and preparations classified as dangerous for the environment do not require to be labelled with the symbol and indication of danger.

PHYSICO-CHEMICAL PROPERTIES
ExplosiveSolid, liquid, pasty or gelatinous substances and preparations which may react exothermically without atmospheric oxygen thereby quickly evolving gases, and which under defined test conditions detonate, quickly deflagrate or upon heating explode when partially confined.E
OxidisingSubstances and preparations which give rise to a highly exothermic reaction in contact with other substances, particularly flammable substances.O
Extremely flammableLiquid substances and preparations having an extremely low flash point and a low boiling point and gaseous substances and preparations which are flammable in contact with air at ambient temperature and pressure.F+
Highly flammableThe following substances and preparations, namely—F

(a)substances and preparations which may become hot and finally catch fire in contact with air at ambient temperature without any application of energy,

(b)solid substances and preparations which may readily catch fire after brief contact with a source of ignition and which continue to burn or to be consumed after removal of the source of ignition,

(c)liquid substances and preparations having a very low flash point, or

(d)substances and preparations which, in contact with water or damp air, evolve extremely flammable gases in dangerous quantities.

FlammableLiquid substances and preparations having a low flash point.none
HEALTH EFFECTS
Very toxicSubstances and preparations which in very low quantities cause death or acute or chronic damage to health when inhaled, swallowed or absorbed via the skin.T+
ToxicSubstances and preparations which in low quantities cause death or acute or chronic damage to health when inhaled, swallowed or absorbed via the skin.T
HarmfulSubstances and preparations which may cause death or acute or chronic damage to health when inhaled, swallowed or absorbed via the skin.Xn
CorrosiveSubstances and preparations which may, on contact with living tissues, destroy them.C
IrritantNon-corrosive substances and preparations which, through immediate, prolonged or repeated contact with the skin or mucous membrane, may cause inflammation.Xi
SensitisingSubstances and preparations which, if they are inhaled or if they penetrate the skin, are capable of eliciting a reaction by hypersensitization such that on further exposure to the substance or preparation, characteristic adverse effects are produced.
Sensitising by inhalationXn
Sensitising by skin contactXi
Carcinogenic (See Note 2)Substances and preparations which, if they are inhaled or ingested or if they penetrate the skin, may induce cancer or increase its incidence
Category 1T
Category 2T
Category 3Xn
Mutagenic (See Note 2)Substances and preparations which, if they are inhaled or ingested or if they penetrate the skin, may induce heritable genetic defects or increase their incidence.
Category 1T
Category 2T
Category 3Xn
Toxic for reproduction (See Note 2)Substances and preparations which, if they are inhaled or ingested or if they penetrate the skin, may produce or increase the incidence of non-heritable adverse effects in the progeny and/or of male or female reproductive functions or capacity.
Category 1T
Category 2T
Category 3Xn
ENVIRONMENTAL EFFECTS
Dangerous for the environment (See Note 3)Substances and preparations which, were they to enter into the environment, would present or might present an immediate or delayed danger for one or more components of the environment.N

Regulations 2(1) and 10(6)

SCHEDULE 2INDICATIONS OF DANGER AND SYMBOLS FOR DANGEROUS SUBSTANCES AND DANGEROUS PREPARATIONS

Column 1Column 2Column 3
Indication of dangerSymbol-letterSymbol
ExplosiveE
OxidisingO
Extremely flammableF+
Highly flammableF
Very toxicT+
ToxicT
HarmfulXn
CorrosiveC
IrritantXi
Dangerous for the environmentN

Regulations 4(7) and 8(3)

SCHEDULE 3PROVISIONS FOR CLASSIFYING DANGEROUS PREPARATIONS

PART IGENERAL PROVISIONS

Application

1.  The provisions of this Schedule shall apply for the classification of preparations.

Interpretation and application

2.—(1) In this Schedule, for the purposes of classification—

“physico-chemcial properities” means the properties to be applied for the classifications “explosive”, “oxidising”, “extremely flammable”, “highly flammable” or “flammable”;

“health effects” means the effects to be assessed for the classifications “very toxic”, “toxic”, “harmful”, “corrosive”, “irritant”, “sensitising”, “carcinogenic”, “mutagenic” or “toxic for reproduction”; and

“environmental hazards” means the hazards to be assessed for the classification “dangerous for the environment”.

(2) In its application to preparations that are gases, this Part shall be modified so that reference to concentrations expressed as percentage by weight are to concentrations expressed as the same percentage by volume.

Classification of preparations by physico-chemical properties

3.—(1) The requisite physico-chemical properties for the classification of preparations shall be determined in accordance with the criteria set out in the approved classification and labelling guide.

(2) Subject to sub-paragraph (3), preparations shall be classified as explosive, oxidising, extremely flammable, highly flammable or flammable when they satisfy the criteria referred to in sub-paragraph (1) for the category of danger.

(3) The determination of explosive, oxidising, extremely flammable, highly flammable or flammable properties is not necessary provided that—

(a)none of the constituents possess such properties and that, on the basis of information available to the manufacturer, the preparation is unlikely to present dangers of this kind;

(b)in the event of a change in composition of a preparation of known composition, scientific evidence indicates that a reassessment of the hazards will not lead to a change in classification; and

(c)in the case of a preparation supplied in the form of an aerosol, that preparation satisfies the provisions of article 9a of Council Directive 75/324/EEC(39).

Classification of preparations by health effects

4.—(1) The health effects of a preparation shall be assessed by one or more of the following methods—

(a)by the conventional method described in the following paragraphs using concentration limits; or

(b)by the criteria set out in the approved classification and labelling guide in relation to the preparation for an appropriate classification and label.

(2) Any one or more of the health effects of the preparation which are not assessed by the method set out in sub-paragraph (1)(b) shall be assessed in accordance with the conventional method.

(3) Where the health effects have been established by both methods, the results of the method set out in sub-paragraph (1)(b shall be used for classifying the preparation except in the case of carcinogenic and mutagenic effects and toxic effects for reproduction, when the conventional method set out in sub-paragraph (1)(a) shall always be used.

(4) Where it can be demonstrated—

(a)by epidemiological studies, by scientifically valid case studies as specified in the approved classification and labelling guide or by statistically backed experience (such as the assessment of data from poison information units or concerning occupational diseases) that toxicological effects on man differ from those suggested by the application of the methods set out in paragraph (1), then the preparation shall be classified according to its effects on man;

(b)that owing to effects such as potentiation, a conventional assessment would underestimate the toxicological hazard, those effects shall be taken into account in classifying the preparation; or

(c)that owing to effects such antagonism, a conventional assessment would overestimate the toxicological hazard, those effects shall be taken into account in classifying the preparation.

(5) Subject to sub-paragraph (6), for preparations of a known composition, with the exception of plant protection products, classified in accordance with the method set out in sub-paragraph (1)(b), a new health effect assessment shall be performed either by the method set out in sub-paragraph (1)(a) or (1)(b) whenever—

(a)changes of composition of the initial concentration, as a weight/weight or volume/volume percentage, of one or more of the dangerous constituents are introduced by the manufacturer which exceed the permitted variations set out in the following table—

Initial concentration range of the constituentPermitted variation in actual concentration of the constituent
≤2.5%±30%
>2.5≤10%±20%
>10≤25%±10%
>25≤100%±5%

(b)changes of composition involving the substitution or addition of one or more constituents, which may or may not be dangerous within the definitions in Schedule 1, are introduced by the manufacturer.

(6) The revised assessment required by paragraph (5) shall not be required where there is a valid scientific justification for considering that a re-evaluation of the hazard will not result in a change of classification.

Classification for health effects by the conventional method

5.—(1) In accordance with paragraph 4(1)(a), the health effects shall be assessed by the conventional method described below using concentration limits.

(2) Where the substances concerned are dangerous substances and are listed as dangerous substances in the approved supply list and are assigned concentration limits necessary for the application of the method of assessment described below, these concentration limits shall be used.

(3) Where the substances concerned are dangerous substances and do not appear in the approved supply list as dangerous substances or appear there without the concentration limits necessary for the application of the method of evaluation described below, the concentration limits shall be assigned in accordance with Part II of this Schedule.

(4) Where a preparation contains at least one substance which, in accordance with regulation 6(7) of the NONS Regulations bears the warning “Caution—Substance not yet fully tested”, the label of the preparation must bear the words “Warning—This preparation contains a substance not yet tested completely” if the substance is present in a concentration equal to or in excess of 1% by weight.

(5) A substance referred to in sub-paragraph (4) must, whatever its concentration level, be treated on the same basis as the other substances present in the preparation when applying the method of evaluation by calculation, if its labelling gives at least an indication of the health effect.

Lower limits of concentration

6.—(1) For preparations to which this Schedule applies, account shall be taken of dangerous substances which are classified as dangerous on the basis of their health or environmental effects (whether they are present as additives or impurities) when their concentrations are equal to or greater than those defined in the following table unless lower limits are given in the approved supply list or in Part II of this Schedule—

Category of danger of the substanceConcentration to take into consideration for
gaseous preparations % vol/volother preparations % w/w
Very toxic≥0.02≥0.1
Toxic≥0.02≥0.1
Carcinogenic Category 1 or 2≥0.02≥0.1
Mutagenic Category 1 or 2≥0.02≥0.1
Toxic for reproduction Category 1 or 2≥0.02≥0.1
Harmful≥0.2≥1
Corrosive≥0.02≥1
Irritant≥0.2≥1
Sensitising≥0.2≥1
Carcinogenic Category 3≥0.2≥1
Mutagenic Category 3≥0.2≥1
Toxic for reproduction Category 3≥0.2≥1
Dangerous for the environment N≥0.1
Dangerous for the environment ozone≥0.1≥0.1
Dangerous for the environment≥1

(2) Some substances may have more than one health effect and each of these properties shall be characterised by its specific concentration limit.

Classification by the conventional method as very toxic

7.—(1) The following preparations shall be classified as very toxic owing to their acute lethal effects and assigned the symbol “T+”, the indication of danger “very toxic” and the risk phrase R26, R27 or R28—

(a)preparations containing one or more substances classified as very toxic that produce such effects, in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 1 of Part II of this Schedule (Table I or Table IA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as very toxic in lower individual concentrations than the limits specified in the approved supply list or in paragraph 1 of Part II of this Schedule (Table I or Table IA), if the sum of the quotients obtained by dividing the percentage weight of each very toxic substance in the preparation by the very toxic limit specified for that substance is 1 or more, i.e.—

where—

PT+

is the percentage by weight of each very toxic substance in the preparation,

LT+

is the very toxic limit specified for each very toxic substance expressed as a percentage by weight or by volume.

(2) The following preparations shall be classified as very toxic owing to their non-lethal irreversible effects after a single exposure and assigned the symbol “T+”, the indication of danger “very toxic” and the risk phrase R39/route of exposure—

Classification by the conventional method as toxic

8.—(1) The following preparations shall be classified as toxic owing to their acute lethal effects and assigned the symbol “T”, the indication of danger “toxic” and the risk phrase R23, R24 or R25—

(a)preparations containing one or more substances classified as very toxic or toxic that produce such effects in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 1 of Part II of this Schedule (Table I or Table IA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as very toxic or toxic in lower individual concentrations than the limits specified in the approved supply list or in paragraph 1 of Part II of this Schedule (Table I or Table IA) if the sum of the quotients obtained by dividing the percentage weight of each very toxic or toxic substance in the preparation by the toxic limit specified for that substance is 1 or more, i.e.—

where—

PT+

is the percentage by weight or by volume of each very toxic substance in the preparation,

PT

is the percentage by weight or by volume of each toxic substance in the preparation,

LT

is the respective toxic limit specified for each very toxic or toxic substance expressed as a percentage by weight or by volume.

(2) The following preparations shall be classified as toxic owing to their non-lethal irreversible effects after a single exposure and assigned the symbol “T”, the indication of danger “toxic” and the risk phrase R39/route of exposure—

Preparations containing one or more dangerous substances classified as very toxic or toxic which produce such effects in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 2 of Part II of this Schedule (Table II or Table IIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

(3) The following preparations shall be classified as toxic owing to their long-term effects and assigned the symbol “T”, the indication of danger “toxic” and the risk phrase R48/route of exposure—

Classification by the conventional method as harmful

9.—(1) The following preparations shall be classified as harmful owing to their acute lethal effects and assigned the symbol “Xn”, the indication of danger “harmful” and the risk phrase R20, R21 or R22—

(a)preparations containing one or more substances classified as very toxic, toxic or harmful and that produce such effects in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 1 of Part II of this Schedule (Table I or Table IA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as very toxic, toxic or harmful in lower individual concentrations than the limits specified in the approved supply list or in paragraph 1 of Part II of this Schedule (Table I or Table IA) if the sum of the quotients obtained by dividing the percentage weight of each very toxic, toxic or harmful substance in the preparation by the harmful limit specified for that substance is 1 or more, i.e.—

where—

PT+

is the percentage by weight or by volume of each very toxic substance in the preparation,

PT

is the percentage by weight or by volume of each toxic substance in the preparation,

PXn

is the percentage by weight or by volume of each harmful substance in the preparation,

LXn

is the respective harmful limit specified for each very toxic, toxic or harmful substance expressed as a percentage by weight or by volume.

(2) The following preparations shall be classified as harmful owing to their acute effects to the lungs if swallowed and assigned the symbol “Xn”, the indication of danger “harmful” and the risk phrase R65—

(3) The following preparations shall be classified as harmful owing to their non-lethal irreversible effects after a single exposure and assigned the symbol “Xn”, the indication of danger “harmful” and the risk phrase R68/route of exposure—

(4) The following preparations shall be classified as harmful owing to their long-term effects and assigned the symbol “Xn”, the indication of danger “harmful” and the risk phrase R48/route of exposure—

Classification by the conventional method as corrosive

10.—(1) The following preparations shall be classified as corrosive and assigned the symbol “C”, the indication of danger “corrosive” and the risk phrase R35—

(a)preparations containing one or more substances classified as corrosive to which is assigned the risk phrase R35 in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as corrosive to which is assigned the risk phrase R35 in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) if the sum of the quotients obtained by dividing the percentage weight of each corrosive substance in the preparation by the corrosive limit R35 specified for that substance is 1 or more, i.e.—

where—

PC.R35

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phase R35 in the preparation,

LC.R35

is the corrosive limit R35 specified for each corrosive substance to which is assigned the risk phase R35 expressed as a percentage by weight or by volume.

(2) The following preparations shall be classified as corrosive and assigned the symbol “C”, the indication of danger “corrosive” and the risk phrase R34—

(a)preparations containing one or more substances classified as corrosive to which is assigned the risk phrase R35 or R34 in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as corrosive to which is assigned the risk phrase R35 or R34 in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) if the sum of the quotients obtained by dividing the percentage weight of each corrosive substance in the preparation by the corrosive limit R34 specified for that substance is 1 or more, i.e.—

where—

PC.R35

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phase R35 in the preparation,

PC.R34

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phase R34 in the preparation,

LC.R34

is the respective corrosive limit R34 specified for each corrosive substance to which is assigned the risk phase R35 or R34 expressed as a percentage by weight or by volume.

Classification by the conventional method as irritant

11.—(1) The following preparations shall be classified as irritants liable to cause serious eye damage and assigned the symbol “Xi”, the indication of danger “irritant” and the risk phrase R41—

(a)preparations containing one or more substances classified as irritant to which is assigned the risk phrase R41 in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as irritant to which is assigned the risk phrase R41, or classified as corrosive and to which is assigned the risk phrase R35 or R34, in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or IVA) if the sum of the quotients obtained by dividing the percentage weight of each irritant substance in the preparation by the irritant limit R41 specified for that substance is 1 or more, i.e.—

where—

PC.R35

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R35 in the preparation,

PC.R34

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R34 in the preparation,

PXi.R41

is the percentage by weight or by volume of each irritant substance to which is assigned the risk phrase R41 in the preparation,

LXi.R41

is the respective irritant limit R41 specified for each corrosive substance to which is assigned the risk phrase R35 or R34 or irritant substance to which is assigned the risk phrase R41, expressed as a percentage by weight or by volume.

(2) The following preparations shall be classified as irritant to eyes and assigned the symbol “Xi”, the indication of danger “irritant” and the risk phrase R36—

(a)preparations containing one or more substances classified as corrosive to which is assigned the risk phrase R35 or R34 or as irritant to which is assigned the risk phrase R41 or R36 in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as irritant to which is assigned the risk phrase R41 or R36 or as corrosive and to which is assigned the risk phrase R35 or R34, in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or IVA) if the sum of the quotients obtained by dividing the percentage weight of each irritant substance in the preparation by the irritant limit R36 specified for that substance is 1 or more, i.e.—

where—

PC. R35

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R35 in the preparation,

PC. R34

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R34 in the preparation,

PXi. R41

is the percentage by weight or by volume of each irritant substance to which is assigned the risk phrase R41 in the preparation,

PXi.R36

is the percentage by weight or by volume of each irritant substance to which is assigned the risk phrase R36 in the preparation,

LXi. R36

is the respective irritant limit R36 specified for each corrosive substance to which is assigned the risk phrase R35 or R34 or irritant substance to which is assigned the risk phrase R41 or R36, expressed as a percentage by weight or by volume.

(3) The following preparations shall be classified as irritant to skin and assigned the symbol “Xi”, the indication of danger “irritant” and the risk phrase R38—

(a)preparations containing one or more substances classified as irritant and to which is assigned the risk phrase R38 or as corrosive and to which is assigned the risk phrase R35 or R34, in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as irritant and to which is assigned the risk phrase R38, or as corrosive and to which is assigned the risk phrase R35 or R34 in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) if the sum of the quotients obtained by dividing the percentage weight of each substance in the preparation by the irritant limit R38 specified for that substance is 1 or more, i.e.—

where—

PC. R35

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R35 in the preparation,

PC. R34

is the percentage by weight or by volume of each corrosive substance to which is assigned the risk phrase R34 in the preparation,

PXi. R38

is the percentage by weight or by volume of each irritant substance to which is assigned the risk phrase R38 in the preparation,

LXi. R38

is the respective irritant limit R38 specified for each corrosive substance to which is assigned the risk phrase R35 or R34 or irritant substance to which is assigned risk phrase R38, expressed as a percentage by weight or by volume.

(4) the following preparations shall be classified as irritant to the respiratory system and assigned the symbol “Xi”, the indication of danger “irritant” and the risk phrase R37—

(a)preparations containing one or more substances classified as irritant to which is assigned the risk phrase R37 in individual concentrations equal to or exceeding—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as irritant to which is assigned the risk phrase R37 in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) if the sum of the quotients obtained by dividing the percentage weight of each irritant substance in the preparation by the irritant limit R37 specified for that substance is 1 or more, i.e.—

where—

PXi. R37

is the percentage by weight or by volume of each irritant substance to which is assigned the risk phrase R37 in the preparation,

LXi. R37

is the irritant limit R37 specified for each irritant substance to which is assigned the risk phrase R37, expressed as a percentage by weight or by volume.

(c)gaseous preparations containing more than one substance classified as irritant and to which is assigned the risk phrase R37 or as corrosive and to which is assigned the risk phrase R35 or R34 in lower individual concentrations than the limits specified either in the approved supply list or in paragraph 4 of Part II of this Schedule (Table IV or Table IVA) if the sum of the quotients obtained by dividing the percentage weight of each substance in the preparation by the irritant limit R37 specified for that substance is 1 or more, i.e.—

where—

PC.R35

is the percentage by volume of each corrosive substance to which is assigned the risk phrase R35 in the preparation,

PC.R.34

is the percentage by volume of each corrosive substance to which is assigned the risk phrase R34 in the preparation,

PXi.R37

is the percentage by volume of each irritant substance to which is assigned the risk phrase R37 in the preparation,

LXi.R37

is the respective irritant limit R37 specified for each gaseous corrosive substance to which is assigned the risk phrase R35 of R34 or gaseous irritant substance to which is assigned risk phrase R37, expressed as a percentage by weight or by volume.

Classification by the conventional method as sensitising

12.—(1) The following preparations shall be classified as sensitising by skin contact and assigned the symbol “Xi”, the indication of danger “irritant” and the risk phrase R43—

(2) The following preparations shall be classified as sensitising by inhalation and assigned the symbol “Xn”, the indication of danger “harmful” and the risk phrase R42—

Classification by the conventional method as carcinogenic

13.—(1) Preparations shall be classified as carcinogenic category 1 or 2 and assigned the symbol “T” and the risk phrase R45 or R49 if they contain one or more substances producing such effects to which is assigned the risk phrase R45 of R49 which denotes carcinogenic substances in category 1 and category 2 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

(2) Preparations shall be classified as carcinogenic category 3 and assigned the symbol “Xn” and the risk phrase R40 if they contain one or more substances producing such effects to which is assigned the risk phrase R40 which denotes carcinogenic substances in category 3 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

Classification by the conventional method as mutagenic

14.—(1) Preparations shall be classified as mutagenic category 1 or 2 and assigned the symbol “T” and the risk phrase R46 if they contain one or more substances producing such effects to which is assigned the risk phrase R46 which denotes mutagenic substances in category 1 and category 2 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

(2) Preparations shall be classified as mutagenic category 3 and assigned the symbol “Xn” and the risk phrase R68 if they contain one or more substances producing such effects to which is assigned the risk phrase R68 which denotes mutagenic substances in category 2 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

Classification by the conventional method as toxic for reproduction

15.—(1) Preparations shall be classified as toxic for reproduction category 1 or 2 and assigned the symbol “T” and the risk phrase R60 (fertility) if they contain one or more substances producing such effects to which is assigned the risk phrase R60 which denotes substances toxic for reproduction of category 1 and category 2 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(2) Preparations shall be classified as toxic for reproduction category 3 and assigned the symbol “Xn” and the risk phrase R62 (fertility) if they contain one or more substances producing such effects to which is assigned the risk phrase R62 which denotes substances toxic for reproduction in category 3 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

(3) Preparations shall be classified as toxic for reproduction category 1 or 2 and assigned the symbol “T” and the risk phrase R61 (development) if they contain one or more substances producing such effects to which is assigned the risk phrase R61 which denotes substances toxic for reproduction of category 1 and category 2 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(4) Preparations shall be classified as toxic for reproduction category 3 and assigned the symbol “Xn” and the risk phrase R63 (development) if they contain one or more substances producing such effects to which is assigned the risk phrase R63 which denotes substances toxic for reproduction in category 3 in individual concentrations equal to or exceeding—

(a)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(b)the concentration specified in paragraph 6 of Part II of this Schedule (Table VI or Table VIA) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits.

Classification of preparations by environmental hazards

16.—(1) The environmental hazards of a preparation shall be assessed by one or more of the following methods—

(a)by the conventional method described in the following paragraphs using concentration limits; or

(b)by the criteria set out in the approved classification and labelling guide in relation to the preparation for an appropriate classification and label.

(2) Where the environmental hazards have been established by both methods, the results of the method set out in sub-paragraph (1)(b) shall be used for classifying the preparation.

(3) Subject to sub-paragraph (4), for preparations of a known composition, with the exception of plant protection products, classified in accordance with the method set out in sub-paragraph (1)(b), a new assessment of the environmental hazards shall be performed either by the method set out in sub-paragraph (1)(a) or (1)(b) whenever—

(a)changes of composition of the initial concentration, as a weight/weight or volume/volume percentage, of one or more of the dangerous constituents are introduced by the manufacturer which exceed the permitted variations set out in the following table—

Initial concentration range of the constituentPermitted variation in actual concentration of the constituent
≤2.5%±30%
>2.5≤10%±20%
>10≤25%±10%
>25≤100%±5%

(b)changes of composition involving the substitution or addition of one or more constituents, which may or may not be dangerous within the definitions in Schedule 1, are introduced by the manufacturer.

(4) The revised assessment required by paragraph (3) shall not be required where there is a valid scientific justification for considering that a re-evaluation of the hazard will not result in a change of classification.

Classification for environmental hazards by the conventional method

17.—(1) In accordance with paragraph 16(1)(a), the environmental hazards shall be assessed by the conventional method described below using concentration limits.

(2) Where the substances concerned are dangerous substances and are listed as dangerous substances in the approved supply list and are assigned concentration limits necessary for the application of the method of assessment described below, these concentration limits shall be used.

(3) where the substances concerned are dangerous substances and do not appear in the approved supply list as dangerous substances or appear there without the concentration limits necessary for the application of the method of evaluation described below, the concentration limits shall be assigned in accordance with Part III of this Schedule.

Conventional method for the evaluation of hazards to the aquatic environment

18.—(1) The following preparations shall be classified as dangerous for the environment and assigned the symbol “N”, the indication of danger “dangerous for the environment” and the risk phrases R50 and R53 (R50-R53)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrases R50-R53 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 1) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrases R50-R53 in lower individual concentrations than the limits specified under paragraph (a) if—

where—

PN. R50—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R50-53 in the preparation,

LN. R50—53

is the limit R50-53 for each substance dangerous for the environment to which is assigned phrases R50-53 expressed as a percentage by weight.

(2) The following preparations shall be classified as dangerous for the environment and assigned the symbol “N”, the indication of danger “dangerous for the environment” and the risk phrases R51 and R53 (R51-R53) unless the preparation is already classified according to sub-paragraph (1)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrases R50-R53 or R51-53 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 1) where the substance or substances do no appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrases R50-R53 or R51-53 in lower individual concentrations than the limits specified under paragraph (a) if—

where—

PN. R50—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R50-53 in the preparation,

PN. R51—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R51-53 in the preparation,

LN. R51—53

is the respective limit R51-53 for each substance dangerous for the environment to which is assigned phrases R50-53 or R51-53 expressed as a percentage of weight.

(3) The following preparations shall be classified as dangerous for the environment and assigned the risk phrases R52 and R53 (R52-R53) unless the preparation is already classified according to sub-paragraph (1) or (2)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrases R50-R53 or R51-53 or R52-53 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 1) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrases R50-R53 or R51-53 or R52-53 in lower individual concentrations that the limits specified under paragraph (a) if—

where—

PN. R50—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R50-53 in the preparation,

PN. R51—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R51-53 in the preparation,

P R52—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R52-53 in the preparation,

L R52—53

is the respective limit R52-53 for each substance dangerous for the environment to which is assigned phrases R50-53, R51-53 or R52-53 expressed as a percentage by weight.

(4) The following preparations shall be classified as dangerous for the environment and assigned the symbol “N”, the indication of danger “dangerous for the environment” and the risk phrase R50 unless the preparation is already classified according to sub-paragraph (1)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrase R50 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 2) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrase R50 in lower individual concentrations than the limits specified under paragraph (a) if—

where—

PN. R50

is the percentage by weight of each substance dangerous for the environment to which is assigned phrase R50 in the preparation,

LN. R50

is the limit R50 for each substance dangerous for the environment to which is assigned phrase R50 expressed as a percentage by weight

(c)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrase R50 not meeting the criteria under paragraph (a) or (b) and containing one or more substances classified as dangerous to the environment and to which is assigned phrases R50-53 if—

where—

PN. R50

is the percentage by weight of each substance dangerous for the environment to which is assigned phrase R50 in the preparation,

PN. R50—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R50-53 in the preparation,

LN. R50

is the respective limit R50 for each substance dangerous for the environment to which is assigned phrases R50 or R50-53 expressed as a percentage by weight.

(5) The following preparations shall be classified as dangerous for the environment and assigned the risk phrase R52 unless the preparation is already classified according to sub-paragraph (1), (2), (3) or (4)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrase R52 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 3) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrase R52 in lower individual concentrations than the limits specified under paragraph (a) if—

where—

P R52

is the percentage by weight of each substance dangerous for the environment to which is assigned phrase R52 in the preparation,

L R52

is the limit R52 for each substance dangerous for the environment to which is assigned phrase R52 expressed as a percentage by weight.

(6) The following preparations shall be classified as dangerous for the environment and assigned the risk phrase R53 unless the preparation is already classified according to sub-paragraph (1), (2) or (3)—

(a)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrase R53 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 4) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits;

(b)preparations containing more than one substance classified as dangerous to the environment and to which is assigned phrase R53 in lower individual concentrations than the limits specified under paragraph (a) if—

where—

P R53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrase R53 in the preparation,

L R53

is the limit R53 for each substance dangerous for the environment to which is assigned phrase R53 expressed as a percentage by weight.

(c)preparations containing one or more substances classified as dangerous to the environment and to which is assigned phrase R53 not meeting the criteria under paragraph (b) and containing one or more substances classified as dangerous to the environment and to which is assigned phrases R50-53, R51-53 or R52-53 if—

where—

P R53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrase R53 in the preparation,

PN. R50—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R50-53 in the preparation,

PN. R51—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R51-53 in the preparation,

P R52—53

is the percentage by weight of each substance dangerous for the environment to which is assigned phrases R52-53 in the preparation,

L R53

is the respective limit R53 for each substance dangerous for the environment to which is assigned phrases R53, R50-53, R51-53 or R52-53 expressed as a percentage by weight.

Conventional method for the evaluation of hazards to the ozone layer

19.—(1) Preparations containing one or more substances classified as dangerous to the environment and to which is assigned the symbol “N” and the risk phrase R59 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 5) where the substance or substances do not appear in the approved supply list or appear in it without concentration limits,

shall be classified as dangerous for the environment and assigned the symbol “N”, the indication of danger “dangerous for the environment” and the risk phrase R59.

(2) Preparations containing one or more substances classified as dangerous to the environment and to which is assigned the risk phrase R59 in individual concentrations equal to or greater than—

(i)either the concentration specified in the approved supply list for the substance or substances under consideration, or

(ii)the concentration specified in Part III of this Schedule (Table 5) where the substance or substances do no appear in the approved supply list or appear in it without concentration limits,

shall be classified as dangerous for the environment and assigned the risk phrase R59.

PART IICONCENTRATION LIMITS TO BE USED IN APPLYING THE CONVENTIONAL METHOD OF ASSESSING HEALTH EFFECTS IN ACCORDANCE WITH PART I OF THIS SCHEDULE WHERE NO SUCH LIMITS ARE GIVEN IN THE APPROVED SUPPLY LIST

An assessment must be made of the health effects that the use of a substance or a preparation might entail.

For that purpose the dangerous health effects have been subdivided into:

1. acute lethal effects;

2. non-lethal irreversible effects after a single exposure;

3. severe effects after repeated or prolonged exposure;

4. corrosive effects, irritant effects;

5. sensitising effects;

6. carcinogenic effects, mutagenic effects, toxic effects for reproduction.

The systematic assessment of the dangerous health effects is expressed by means of concentration limits, expressed as weight/weight percentage except for gaseous preparations (Tables A) where they are expressed as a volume/volume percentage and in conjunction with the classification of a substance.

The classification of the substance is expressed either by a symbol and one or more risk phrases or by categories (category 1, category 2 or category 3) also expressed by risk phrases when substances are shown to be carcinogenic, mutagenic or toxic for reproduction. Therefore it is important to consider, in addition to the symbol, all the phrases denoting specific risks which are assigned to each substance under consideration.

Acute lethal effects

1.1  Other than gaseous preparations

Gaseous preparations

1.2  The concentration limits expressed as a volume/volume percentage in Table 1A determine the classification of the gaseous preparations in relation to the individual concentration of the gas(es) present whose classification is also shown.

Table IA
Classification of the substance (gas)Classification of the preparation
T+TXn
T+ with R26, R27, R28concentration ≥1%0.2%≤ concentration <1%0.02%≤ concentration <0.2%
T with R23, R24, R25concentration ≥5%0.5%≤ concentration <5%
Xn with R20, R21, R22concentration ≥5%

The R phrases denoting risk shall be assigned to the preparation in accordance with the following criteria—

(i)the label shall include one or more of the above mentioned R phrases according to the classification used,

(ii)in general, the R phrases selected should be those applicable to the substance(s) present in the concentration which gives rise to the most severe classification.

Non-lethal irreversible effects after a single exposure

Other than gaseous preparations

2.1  For substances that produce non-lethal irreversible effects after a single exposure (R39/route of exposure, R68/route of exposure), the individual concentration limits specified in Table II determine, when appropriate, the classification of the preparation.

Table II
Classification of the substanceClassification of the preparation
T+TXn
(*)

In order to indicate the route of administration/exposure the combined R phrases listed in Part V of the approved supply list shall be used.

(†)

R68 here refers to substances classified as harmful. Concentration limits for substances required to be labelled R68 but classified as carcinogenic or mutagenic are given in Table VI.

T+ with R39/route of exposureconcentration ≥10% R39 (*) obligatory1%≤ concentration <10% R39(*) obligatory0.1%≤ concentration <1% R68(*)(†) obligatory
T with R39/route of exposureconcentration ≥10% R39(*) obligatory1%≤ concentration <10% R68(*)(†) obligatory
Xn with R68/route of exposureconcentration ≥10% R68(*)(†) obligatory

Gaseous preparations

2.2  For gases that produce non-lethal irreversible effects after a single exposure (R39/route of exposure, R68/route of exposure), the individual concentration limits specified in Table IIA, expressed as a volume/volume percentage, determine, when appropriate, the classification of the preparation.

Table IIA
Classification of the substance (gas)Classification of the preparation
T+TXn
(*)

In order to indicate the route of administration/exposure the combined R phrases listed in Part V of the approved supply list shall be used.

(†)

R68 here refers to substances classified as harmful. Concentration limits for substances required to be labelled R68 but classified as carcinogenic or mutagenic are given in Table VI.

T+ with R39/route of exposureconcentration ≥1% R39(*) obligatory0.2%≤concentration <1% R39(*) obligatory0.02%≤concentration <0.2% R68(*)(†) obligatory
T with R39/route of exposureconcentration ≥5% R39(*) obligatory0.5%≤concentration <5% R68(*)(†) obligatory
Xn with R68/route of exposureconcentration ≥5% R68(*)(†) obligatory

Severe effects after repeated or prolonged exposure

Other than gaseous preparations

3.1  For substances that produce severe effects after repeated exposure (R48/route of exposure), the individual concentration limits specified in Table III determine, when appropriate, the classification of the preparation.

Table III
Classification of the substanceClassification of the preparation
TXn
(*)

In order to indicate the route of administration/exposure the combined R phrases listed in Part V of the approved supply list shall be used.

T with R48/route of exposureconcentration ≥10% R48 (*) obligatory1% ≤concentration <10% R48(*) obligatory
Xn with R48/route of exposureconcentration ≥10% R48(*) obligatory

Gaseous preparations

3.2  For gases that produce severe effects after repeated or prolonged exposure (R48/route of exposure), the individual concentration limits specified in Table IIIA, expressed as a volume/volume percentage, determine, when appropriate, the classification of the preparation.

Table IIIA
Classification of the substance (gas)Classification of the preparation
TXn
(*)

In order to indicate the route of administration/exposure the combined R phrases listed in Part V of the approved supply list shall be used.

T with R48/route of exposureconcentration ≥5% R48 (*) obligatory0.5% ≤concentration <5% R48(*) obligatory
Xn with R48/route of exposureconcentration ≥5% R48(*) obligatory

Corrosive and irritant effects including serious damage to eye

Other than gaseous preparations

4.1  For substances that produce corrosive effects (R34, R35) or irritant effects (R36, R37, R38, R41), the individual concentration limits specified in Table IV determine, when appropriate, the classification of the preparation.

Table IV
Classification of the substanceClassification of the preparation
C with R35C with R34Xi with R41Xi with R36, R37, R38
(*)

According to the approved classification and labelling guide, when a substance or preparation is classified as corrosive and assigned the risk phrase R34 or R35, the risk of severe damage to the eyes is considered implicit and the risk phrase R41 is not included on the label. Consequently, if the preparation contains corrosive substances with R35 or R34 below the concentration limits for a classification of the preparation as corrosive, such substances can contribute to a classification of the preparation as irritant (R41) or irritant (R36).

C with R35concentration ≥10% R35 obligatory5%≤concentration <10% R34 obligatory5%(*)1%≤concentration <5% R36/38 obligatory
C with R34concentration ≥10% R34 obligatory10%(*)5%≤concentration <10% R36/38 obligatory
Xi with R41concentration ≥10% R41 obligatory5%≤concentration <10% R36 obligatory
Xi with R36, R37, R38concentration ≥20% R36, R37, R38 are obligatory in the light of the concentration present if they apply to the substances under consideration

Note

Simple application of the conventional method to preparations containing substances classified as corrosive or irritant may result in under-classification or over-classification of the hazard, if other relevant factors (e.g. pH of the preparation) are not taken into account. Therefore, in classifying for corrosivity, consider the advice given in the approved classification and labelling guide regarding classification as corrosive and paragraph 4(4)(b) and (c) of Part I of this Schedule.

Gaseous preparations

4.2  For gases that produce such effects (R34, R35—or R36, R37, R38, R41), the individual concentration limits specified in Table IVA, expressed as a volume/volume percentage determine, when appropriate, the classification of the preparation.

Table IVA
Classification of the substance (gas)Classification of the preparation
C with R35C with R34Xi with R41Xi with R36, R37, R38
(*)

According to the approved classification and labelling guide, when a substance or preparation is classified as corrosive and assigned the risk phrase R34 or R35, the risk of severe damage to the eyes is considered implicit and the risk phrase R41 is not included on the label. Consequently, if the preparation contains corrosive substances with R35 or R34 below the concentration limits for a classification of the preparation as corrosive, such substances can contribute to a classification of the preparation as irritant (R41) or irritant (R36).

C with R35concentration ≥1% R35 obligatory0.2%≤concentration <1% R34 obligatory0.2%(*)0.02%≤ concentration <0.2% R36/37/38 obligatory
C with R34concentration ≥5% R34 obligatory5%(*)0.5%≤concentration <5% R36/37/38 obligatory
Xi with R41concentration ≥5% R41 obligatory0.5%≤concentration <5% R36 obligatory
Xi with R36, R37, R38concentration ≥5% R36, R37, R38 obligatory as appropriate

Note

Simple application of the conventional method to preparations containing substances classified as corrosive or irritant may result in under-classification or over-classification of the hazard, if other relevant factors (e.g. pH of the preparation) are not taken into account. Therefore, in classifying for corrosivity, consider the advice given in the approved classification and labelling guide regarding classification as corrosive and paragraph 4(4)(b) and (c) of Part I of this Schedule.

Sensitising effects

Other than gaseous preparations

5.1  Preparations that produce such effects are classified as sensitising and assigned:

The individual concentration limits specified in Table V determine, when appropriate, the classification of the preparation.

Table V
Classification of the substanceClassification of the preparation
Sensitising with R42Sensitising with R43
Sensitising with R42concentration ≥1% R42 obligatory
Sensitising with R43concentration ≥1% R43 obligatory

Gaseous preparations

5.2  Gases that produce such effects are classified as sensitising and assigned:

The individual concentration limits specified in Table VA, expressed as a volume/volume percentage, determine, when appropriate, the classification of the preparation.

Table VA
Classification of the substance (gas)Classification of the gaseous preparation
Sensitising with R42Sensitising with R43
Sensitising with R42concentration ≥0.2% R42 obligatory
Sensitising with R43concentration≥0.2% R43 obligatory

Carcinogenic/mutagenic/toxic effects for reproduction

Other than gaseous preparations

6.1  For substances which produce such effects and for which specific concentration limits do not yet appear in the approved supply list, concentration limits laid down in Table VI shall determine, where appropriate, the classification of the preparation.

The following symbol and risk phrases are assigned:

Carcinogenic categories 1 and 2:T; R45 or R49
Carcinogenic category 3:Xsubn;; R40
Mutagenic categories 1 and 2:T; R46
Mutagenic category 3:Xn R68
Toxic for reproduction fertility categories 1 and 2:T; R60
Toxic for reproduction development categories 1 and 2:T; R61
Toxic for reproduction fertility category 3:Xn; R62
Toxic for reproduction development category 3:Xn; R63
Table VI
Classification of the substanceClassification of the preparation
Categories 1 and 2Category 3
(*)

R68 here refers to substances classified as mutagenic. Concentration limits for substances required to be labelled R68 but classified as harmful are given in Table II.

Carcinogenic substances of category 1 or 2 with R45 or R49concentration≥0.1% carcinogenic R45, R49 obligatory as appropriate
Carcinogenic substances of category 3 with R40concentration ≥1% carcinogenic R40 obligatory
Mutagenic substances of category 1 or 2 with R46concentration ≥0.1% mutagenic R46 obligatory
Mutagenic substances of category 3 with R68(*)concentration ≥1% mutagenic R68(*) obligatory
Substances “toxic for reproduction” of category 1 or 2 with R60 (fertility)concentration ≥0.5% toxic for reproduction (fertility) R60 obligatory
Substances “toxic for reproduction” of category 3 with R62 (fertility)concentration ≥5% toxic for reproduction (fertility) R62 obligatory
Substances “toxic for reproduction” of category 1 or 2 with R61 (development)concentration ≥0.5% toxic for reproduction (development) R61 obligatory
Substances “toxic for reproduction” of category 3 with R63 (development)concentration ≥5% toxic for reproduction (development) R63 obligatory

Gaseous preparations

6.2  For gases which produce such effects and for which specific concentration limits do not yet appear in the approved supply list, concentration limits laid down in Table VIA, expressed as a volume/volume percentage, shall determine, where appropriate, the classification of the preparation.

The following symbol and risk phrases are assigned:

Carcinogenic categories 1 and 2:T; R45 or R49
Carcinogenic category 3:Xn; R40
Mutagenic categories 1 and 2:T; R46
Mutagenic category 3:Xn; R68
Toxic for reproduction fertility categories 1 and 2:T; R60
Toxic for reproduction development categories 1 and 2:T; R61
Toxic for reproduction fertility category 3:Xn; R62
Toxic for reproduction development category 3:Xn; R63
Table VIA
Classification of the substance (gas)Classification of the gaseous preparation
Categories 1 and 2Category 3
(*)

R68 here refers to substances classified as carcinogenic or mutagenic. Concentration limits for substances required to be labelled R68 but classified as harmful are given in Table IIA

Carcinogenic substances of category 1 or 2 with R45 or R49concentration ≥0.% carcinogenic R45, R49 obligatory as appropriate
Carcinogenic substances of category 3 with R40concentration ≥1% carcinogenic R40 obligatory
Mutagenic substances of category 1 or 2 with R46concentration ≥0.1% mutagenic R46 obligatory
Mutagenic substances of category 3 with R68(*)concentration ≥1% mutagenic R68(*) obligatory
Substances “toxic for reproduction” of category 1 or 2 with R60 (fertility)concentration ≥0.2% toxic for reproduction (fertility) R60 obligatory
Substances “toxic for reproduction” of category 3 with R62 (fertility)concentration ≥1% toxic for reproduction (fertility) R62 obligatory
Substances “toxic for reproduction” of category 1 or 2 with R61 (development)concentration ≥0.2% toxic for reproduction (development) R61 obligatory
Substances “toxic for reproduction” of category 3 with R63 (development)concentration ≥1% toxic for reproduction (development) R63 obligatory

PART IIICONCENTRATION LIMITS TO BE USED FOR THE EVALUATION OF ENVIRONMENT HAZARDS

The aquatic environment

1.  The concentration limits fixed in the following tables, expressed as a weight/weight percentage, determine the classification of the preparation in relation to the individual concentration of the substances present whose classification is also shown.

Table 1:
Acute aquatic toxicity and long-term adverse effects
Classification of the substanceClassification of the preparation
N, R50-53N, R51-53R52-53
N, R50-53Cn≥25%2.5%≤ Cn<25%0.25%≤Cn<2.5%
N, R51-53Cn≥25%2.5%≤Cn<25%
R52-53Cn≥25%
Table 2
Acute aquatic toxicity
Classification of the substanceClassification of the preparation N, R50
N, R50Cn ≥ 25%
N, R50-53Cn ≥ 25%
Table 3
Aquatic toxicity
Classification of the substanceClassification of the preparation R52
R52Cn ≥ 25%
Table 4
Long-term adverse effects
Classification of the substanceClassification of the preparation R53
R53Cn ≥ 25%
N, R50-53Cn ≥ 25%
N, R51-53Cn ≥ 25%
R52-53Cn ≥ 25%

The non-aquatic environment

2.  The concentration limits fixed in the following table, expressed as a weight/weight percentage or, for gaseous preparations as a volume/volume percentage, determine the classification of the preparation in relation to the individual concentration of the substances present whose classification is also shown.

Table 5
Dangerous for the ozone layer
Classification of the substanceClassification of the preparation N, R59
N with R59Cn ≥ 0.1%
Classification of the substanceClassification of the preparation R59
R59Cn ≥ 0.1%

Regulation 5

SCHEDULE 4HEADINGS UNDER WHICH PARTICULARS ARE TO BE PROVIDED IN SAFETY DATA SHEETS

The safety data sheet referred to in regulation 5 shall contain the following headings:

1.  Identification of the substance or preparation and the company/undertaking.

2.  Composition/information on ingredients.

3.  Hazards identification.

4.  First-aid measures.

5.  Fire-fighting measures.

6.  Accidental release measures.

7.  Handling and storage.

8.  Exposure controls and personal protection.

9.  Physical and chemical properties.

10.  Stability and reactivity.

11.  Toxicological information.

12.  Ecological information.

13.  Disposal considerations.

14.  Transport information.

15.  Regulatory information.

16.  Other information.

Regulations 3(2), 8 and 9

SCHEDULE 5LABELLING PARTICULARS FOR DANGEROUS SUBSTANCES, DANGEROUS PREPARATIONS AND FOR CERTAIN OTHER PREPARATIONS

PART IGENERAL PROVISIONS RELATING TO LABELS

Labelling particulars for dangerous substances

1.—(1) In the case of a dangerous substance which is listed in the approved supply list, the particulars to be shown on the label in accordance with regulation 8(2)(c) shall be the particulars specified for that dangerous substance in the relevant entry in Part I of that list.

(2) Subject to paragraph 4, in the case of a dangerous substance which is not listed in the approved supply list, the particulars required to be shown on the label in accordance with regulation 8(2)(c) shall be determined from the classification of the substance in accordance with regulation 4 in conjunction with the approved classification and labelling guide.

Labelling particulars for dangerous preparations

2.—(1) Subject to paragraphs 3 and 4, the provisions of this paragraph shall have effect in relation to the labelling of dangerous preparations.

(2) Subject to sub-paragraph (4), the particulars relating to chemical name required to be shown on the label in accordance with regulation 8(3)(c)(i) shall be shown according to the following rules—

(a)in the case of a dangerous preparation classified as requiring the indication of danger T+, T or Xn, only substances requiring those indications of danger present in the dangerous preparation in concentrations equal to or greater than—

(i)the lowest limit (the Xn limit) for the substance laid down in Part I of the approved supply list, or

(ii)where there is no such limit, the relevant limit laid down in Part II of Schedule 3,

have to be taken into consideration;

(b)in the case of a dangerous preparation classified as requiring the indication of danger C, only substances requiring that indication of danger present in the dangerous preparation in concentrations equal to or greater than—

(i)the lowest limit (the Xi limit) for the substance laid down in Part I of the approved supply list, or

(ii)where there is no such limit, the relevant limit laid down in Part II of Schedule 3,

have to be taken into consideration;

(c)if the dangerous preparation is assigned one or more of the following danger categories:

the name of any substance causing the dangerous preparation to be so assigned shall be referred to;

(d)as a consequence of the provisions set out in paragraphs (a) to (c), the name of any substance which led to the classification of the dangerous preparation in the following danger categories:

need not be referred to on the label unless so required by paragraph (a), (b) or (c).

(3) The chemical name referred to in sub-paragraph (2) shall be—

(a)in the case of a substance listed in Part I of the approved supply list, the name or one of the names under which that substance is listed; or

(b)in the case of a substance not so listed, an internationally recognised name.

(4) For the purpose of labelling, no account shall be taken of a substance in the dangerous preparation where the concentration of that substance is less than the concentration referred to in paragraph 22(1) of Part I of Schedule 3.

(5) Subject to sub-paragraph (4), the particulars to be shown on the label in accordance with regulation 8(3)(c)(ii), (iii) and (iv) shall be determined from the classification of the dangerous preparation made in accordance with regulation 4 in conjunction with the approved classification and labelling guide.

(6) As a general rule, a maximum of four chemical names shall suffice to identify the substances primarily responsible for the major health hazards which have given rise to the classification and the choice of the corresponding risk phrases—although in some cases more than four chemical names may be necessary.

Confidentiality of chemical names

3.—(1) Subject to sub-paragraph (2), where the supplier of a dangerous preparation is able to demonstrate to the Executive that the disclosure on the label or safety data sheet of the chemical identity of a substance which is exclusively classified as—

(a)irritant with the exception of those assigned R41 or irritant in combination with one or more of the other properties mentioned in paragraph (2)(2)(d); or

(b)harmful or harmful in combination with one or more of the properties mentioned in paragraph 2(2)(d) presenting acute lethal effects alone,

will put at risk the confidential nature of his intellectual property, he shall, in accordance with the provisions of Annex VI to Council Directive 1999/45/EC(40), be permitted to refer to that substance either by means of a name that identifies the most important functional chemical groups or by means of an alternative name.

(2) The derogation in sub-paragraph (1) shall not apply in respect of a substance which has been assigned a Community exposure limit.

(3) Where a supplier wishes to take advantage of the derogation contained in sub-paragraph (1), he shall make application to the Executive accordingly, enclosing the information specified in Annex VI to Council Directive 1999/45/EC.

(4) The Executive may require such further information from the supplier as is necessary to determine the validity of an application made under sub-paragraph (3).

(5) Regulation 18 of the NONS Regulations (which relates to confidentiality of information notified) shall apply to information provided in accordance with sub-paragraph (2) as it applies to information notified under those Regulations.

Indications of danger and symbols for dangerous substances and dangerous preparations

4.—(1) Except in the case of a dangerous substance which is listed in the approved supply list, where a dangerous substance or dangerous preparation is required to have more than one indication of danger in either of the following groups listed in decreasing order of severity, namely—

(a)explosive, oxidising, extremely flammable and highly flammable; or

(b)very toxic, toxic, corrosive, harmful and irritant,

only one of the indications of danger with its symbol from each group corresponding to the most severe indication of danger in that group need be shown.

(2) The risk phrases R12 (extremely flammable) and R11 (highly flammable) need not be used if they repeat the indication of danger shown on the label.

PART IIPARTICULAR PROVISIONS CONCERNING CERTAIN PREPARATIONS

ASPECIAL PROVISIONS FOR DANGEROUS PREPARATIONS

Dangerous preparations to be supplied to the general public

1.—(1) The labels on packages of dangerous preparations intended to be supplied to the general public must bear relevant safety phrase S1, S2, S45 or S46 in accordance with the approved classification and labelling guide.

(2) When the dangerous preparations referred to in sub-paragraph (1) are classified as very toxic, toxic or corrosive and where it is physically impossible to give the information on the package itself, packages containing such preparations must be accompanied by precise and easily understandable instructions for use including, where appropriate, instructions for the destruction of the empty package.

Dangerous preparations intended for use by spraying

2.  The labels on packages containing dangerous preparations intended to be used for spraying shall bear the safety phrase S23 and safety phrase S38 or S51 assigned in accordance with the approved classification and labelling guide.

Dangerous preparations containing a substance affected by the risk phrase R33 (danger of cumulative effects)

3.  When a dangerous preparation contains at least one substance required to show the risk phrase R33, that phrase must be shown on the label of the dangerous preparation when the concentration of that substance is equal to or higher than 1% unless a different value is shown for that substance in the approved supply list.

Dangerous preparations containing a substance affected by the risk phrase R64 (may cause harm to breast-fed babies)

4.  When a dangerous preparation contains at least one substance required to show the risk phrase R64, that phrase must be shown on the label of the dangerous preparation when the concentration of that substance is equal to or higher than 1% unless a different value is shown for that substance in the approved supply list.

BSPECIAL PROVISIONS APPLYING TO ANY PREPARATION

Paints and varnishes containing lead

1.—(1) Labels of packages of paints and varnishes containing lead in quantities exceeding 0.15% (expressed as weight of lead out of the total weight of the preparation and determined in accordance with ISO Standard 6503/1984) shall bear the following inscription—

(2) In the case of packages containing less than 125 millilitres of the preparations referred to in sub-paragraph (1), the inscription on the label may be—

Cyanoacrylate based adhesives

2.—(1) The immediate packages of glues based on cyanoacrylates shall bear the following inscription—

(2) Appropriate safety advice shall accompany the package.

Preparations containing isocyanates

3.  The package labels of preparations containing isocyanates (whether as monomers, oligomers, prepolymers etc. or as mixtures thereof) shall bear the following inscriptions—

Certain preparations containing epoxy constituents

4.  The package labels of preparations containing epoxy constituents with an average molecular weight ≤700 shall bear the following inscription—

Preparations intended to be sold to the general public that contain active chlorine

5.  The package labels of preparations containing more than 1% of active chlorine which are intended to be sold to the general public shall bear the following inscription—

Preparations containing cadmium (alloys) intended to be used for brazing or soldering

6.  The package labels of preparations containing cadmium (alloys) intended to be used for brazing or soldering shall bear the following inscriptions—

Preparations containing substances not yet tested completely

7.  Where a preparation contains at least one substance which, in accordance with regulation 6(7) of the NONS Regulations, bears the inscription “Caution—substance not yet fully tested”, the label of the preparation must bear the inscription “Warning—this preparation contains a substance not yet tested completely” if that substance is present in a concentration ≥1%.

Preparations not classified as sensitising but containing at least one sensitising substance

8.  The packaging of preparations containing at least one substance classified as sensitising and being present in a concentration ≥ 0.1% or in a concentration greater than or equal to that specified under a specific note for the substance in the approved supply list must bear the inscription—

Liquid preparations containing halogenated hydrocarbons

9.  For liquid preparations which show no flashpoint or a flashpoint higher than 55°C and contain a halogenated hydrocarbon and more than 5% flammable or highly flammable substances, the packaging must bear the following inscription as appropriate—

Preparations containing a substance assigned the risk phrase R67

10.  When a preparation contains one or more substances assigned the risk phrase R67, the label of the preparation must bear the following inscription—

Cement and cement preparations

11.  The packaging of cements and cement preparations containing more than 0.0002% soluble chromium (VI) of the total dry weight of the cement must bear the inscription:

CSPECIAL PROVISIONS APPLYING TO CERTAIN OTHER PREPARATIONS

Preparations not intended for the general public

1.  The label on the packaging of a preparation of the type specified in regulation 5(3) must bear the following inscription—

Regulation 11

SCHEDULE 6BRITISH AND INTERNATIONAL STANDARDS RELATING TO CHILD RESISTANT FASTENINGS AND TACTILE WARNING DEVICES

The British and International Standards referred to in regulation 11 are as follows—

“BS EN 28317” means the British Standard Specification for packagings resistant to opening by children, BS EN 28317: 1993 which was published by the British Standards Institution and came into effect on 15 February 1993;

“ISO 8317” means the International Standard ISO 8317 (1 July 1989 edition) relating to “Child-resistant packagings—Requirements for the testing of reclosable packages” adopted by the International Standards Organisation;

“BS 6652” means the British Standard Specification for packagings resistant to opening by children, BS 6652: 1989 which was published by the British Standards Institution and came into effect on 30 June 1989;

“EN 862” means CEN Standard EN 862 (March 1997 Edition) relating to “Packaging—Child-resistant packaging—Requirements and testing procedures for non-reclosable packages for non-pharmaceutical products” adopted by the European Committee for Standardisation;

“EN ISO 11683” means EN ISO Standard 11683 (1997 Edition) relating to “Packaging—Tactile warnings of danger”—Requirements;

“BS 7501” means the British Standard on the general criteria for the operation of testing laboratories BS 7501: 1989 which was published by the British Standards Institution and came into effect on 31 October 1989;

“EN 45 000” means European Standards Series 45 000 which sets out the general criteria which laboratories must adhere to in order to obtain accreditation for the certification of child resistant fastenings.

Regulation 18(1)

SCHEDULE 7REVOCATIONS

123
Regulations revokedReferencesExtent of revocation
The Chemicals (Hazard Information and Packaging for Supply) Regulations 1994S.I. 1994/3247The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 1996S.I. 1996/1092The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 1997S.I. 1997/1460The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 1998S.I. 1998/3106The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 1999S.I. 1999/197The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) (No. 2) Regulations 1999S.I. 1999/3165The whole Regulations
The Chemicals (Hazard Information and Packaging for Supply) (Amendment) Regulations 2000S.I. 2000/2381The whole Regulations

Explanatory Note

(This note is not part of the Regulations)

1.  These Regulations revoke and re-enact with amendments the Chemicals (Hazard Information and Packaging for Supply) Regulations 1994 (S.I. 1994/3247).

2.  By virtue of the amendments to the European Communities Act 1972 (c. 68) made by the European Economic Area Act 1993 (c. 51), these Regulations make provisions relating to the European Economic Area as defined in regulation 2(1) of these Regulations.

3.  These Regulations, as respects Great Britain, implement—

(a)Council Directive 1992/32/EEC (OJ No. L154, 5.6.92, p.1) amending for the 7th time Council Directive 67/548/EEC (OJ No. L196, 16.8.67, p.1), in so far as its provisions relate to the classification, packaging and labelling of dangerous substances (“the substances Directive”);

(b)Council Directive 1999/45/EC (OJ No. L 200, 30.7.99, p.1) on the classification, packaging and labelling of dangerous preparations (“the preparations Directive”);

(c)points 29, 30 and 31 of Annex I to Council Directive 76/769/EEC (OJ No. L262, 27.9.76, p. 201) as most recently amended by Directive 2001/41/EC of the European Parliament and of the Council (OJ No. L194, 18.7.01, p. 36); and

(d)Commission Directive 91/155/EEC (OJ No. L 76, 22.3.91, p.39) on the provision of safety data sheets (“the safety data sheets Directive”).

4.  These Regulations also implement the Directives referred to below which adapt to technical progress and modify the substances Directive, the preparations Directive and the safety data sheets Directive. These Directives are—

(a)Commission Directive 91/410/EEC (OJ No. L 228, 17.8.91, p.67) 14th adaptation to technical progress of the substances Directive;

(b)Commission Directive 92/37/EEC (OJ No. L 154, 5.6.92, p.30) 16th adaptation to technical progress of the substances Directive;

(c)Commission Directive 93/21/EEC (OJ No. L 110, 4.5.93, p.20) 18th adaptation to technical progress of the substances Directive;

(d)Commission Directive 93/72/EEC (OJ No. L 258, 16.10.93, p.29) 19th adaptation to technical progress of the substances Directive;

(e)Commission Directive 93/101/EEC (OJ No. L 13, 15.1.94, p.1) 20th adaptation to technical progress of the substances Directive;

(f)Commission Directive 93/112/EC (OJ No. L 314, 16.12.93, p.38) amendment to the safety data sheets Directive;

(g)Commission Directive 94/69/EC (OJ No. L 381, 31.12.94) 21st adaptation to technical progress of the substances Directive;

(h)Commission Directive 96/54/EC (OJ No. L 248, 30.9.96) 22nd adaptation to technical progress of the substances Directive;

(i)Commission Directive 97/69/EC (OJ No. L343, 13.12.97, p.19) 23rd adaptation to technical progress of the substances Directive;

(j)Commission Directive 98/73/EC (OJ No. L 305, 16.11.98) 24th adaptation to technical progress of the substances Directive;

(k)Commission Directive 98/98/EC (OJ No. L355, 30.12.98) 25th adaptation to technical progress of substances Directive;

(l)Commission Directive 2000/32/EC (OJ No. L 136, 8.6.2000, p.1) 26th adaptation to technical progress of the substances Directive;

(m)Commission Directive 2000/33/EC (OJ No. L136, 8.6.2000, p.90) 27th adaptation to technical progress of the substances Directive;

(n)Commission Directive 2001/58/EC (OJ No. L 212, 7.8.2001, p.24) 2nd amendment to the safety data sheets Directive;

(o)paragraphs 1 and 5 of article 1 of Commission Directive 2001/59/EC (OJ No. L 225, 21.8.2001, p.1) 28th adaptation to technical progress of the substances Directive;

(p)Commission Directive 2001/60/EC (OJ No. L 226, 22.8.2001, p.5) 1st adaptation to technical progress of the preparations Directive.

5.  The terms and expressions used in the Regulations are defined in regulation 2 and the scope of the Regulations is described in regulation 3.

6.  Regulation 4 describes the procedures for classifying dangerous substances and dangerous preparations and regulation 5 describes the safety data sheets which (with certain exceptions) are required to be provided when dangerous substances, dangerous preparations and certain other preparations are supplied. Regulation 6 requires that advertisements for dangerous substances and dangerous preparations must refer to the hazards presented by that dangerous substance or dangerous preparation.

7.  Regulation 7 imposes requirements relating to the packaging of dangerous substances and dangerous preparations and regulation 8 imposes requirements in respect of the particulars that must be shown on the labels for such substances and preparations.

8.  Special labelling requirements for certain preparations are imposed in regulation 9 and regulation 10 imposes requirements in respect of the methods of marking and labelling packages which contain dangerous substances or dangerous preparations.

9.  Regulation 11 requires that the packaging of certain substances and preparations be provided with child resistant fastenings or tactile warning devices or both, and sets out the standards to which they must conform.

10.  The Regulations also require a person who classifies a dangerous preparation to retain the data used for the classification for at least 3 years after the preparation was last supplied (regulation 12).

11.  The Regulations make provision for exemptions to be granted by the Health and Safety Executive in certain circumstances (regulation 13) and for their enforcement (regulation 14).

12.  Regulation 15 provides for a defence in specific circumstances in the case of contravention of the Regulations. Transitional provisions are set out in regulation 16 and provision is made in regulation 17 to extend the application of the Regulations outside Great Britain. Revocations and modifications are set out in regulation 18.

13.  Copies of the publications referred to in the Regulations are obtainable as follows—

(a)the approved supply list (ISBN 0 7176 2368 8), and the approved classification and labelling guide (ISBN 0 7176 2369 6), from HSE Books, PO Box 1999, Sudbury, Suffolk CO10 6FS (Telephone: 01787 881165; Fax 01787 313995); and good booksellers.

(b)the British and International Standards referred to in regulation 11 and Schedule 6 (relating to child resistant fastenings and tactile warning devices) from (by personal callers) the British Standards Institution, 2 Part Street, London W1A 2BS or (by post) from the British Standards Institution, Linford Wood, Milton Keynes, MK14 6LE.

14.  A copy of the regulatory impact assessment prepared in respect of these Regulations can be obtained from the Health and Safety Executive, Economic Advisers Unit, Rose Court, 2 Southwark Bridge, London SE1 9HS. A copy of the transposition note in relation to implementation of the Directives set out in paragraphs 3 and 4 can be obtained from the Health and Safety Executive, International Branch at the same address. Copies of both these documents have been placed in the Library of each House of Parliament.

(3)

As regards Scotland, see also section 57(1) of the Scotland Act 1998 (c. 46), which provides that, despite the transfer to the Scottish Ministers by virtue of that Act of functions in relation to observing and implementing obligations under Community law, any function of a Minister of the Crown in relation to any matter shall continue to be exercisable by him as regards Scotland for the purposes specified in section 2(2) of the European Communities Act 1972.

(4)

1974 c. 37; sections 15(1) and 50(3) were amended by the Employment Protection Act 1975 (c. 71), Schedule 15, paragraphs 6 and 16(3) respectively.

(5)

S.I. 1996/2092, as amended by S.I.s 1998/2885 and S.I. 1999/303.

(6)

The Agreement was amended by Decision 7/94 of the EEA Joint Committee of 21st March 1994 (OJ No. L160, 28.6.94, p. 1). There are other amendments to the Agreement which are not relevant to these Regulations.

(8)

OJ No. C146A, 15.6.90, p.1.

(9)

OJ No. C130, 10.5.93, p.1.

(10)

S.I. 1993/3050, to which there are amendments not relevant to these Regulations.

(11)

S.I. 1995/887, to which there are amendments not relevant to these Regulations.

(14)

S.I. 1996/2925, to which there are amendments not relevant to these Regulations.

(15)

S.I. 1994/1056, to which there are amendments not relevant to these Regulations.

(16)

S.I. 1996/972, to which there are amendments not relevant to these Regulations.

(18)

1970 c. 40; section 66(1) was modified by S.I. 1991/2840.

(20)

O.J. No. L251, 29.8.92, p.13.

(21)

S.I. 1986/1510, to which there are amendments not relevant to these Regulations.

(25)

S.I. 1994/2844, as amended by S.I. 1996/2635.

(28)

S.I. 1972/917, to which there are amendments not relevant to these Regulations.

(30)

S.I. 1986/1510, to which there are amendments not relevant to these Regulations.

(32)

1968 c. 67; section 75(8) was amended by S.I. 1968/1699.

(33)

1987 c. 43; section 11(7)(c) is amended by section 16(1) of, and paragraph 15 of Schedule 4 to, the Gas Act 1995.

(36)

S.I. 1986/1510, to which there are amendments not relevant to these Regulations.

(37)

O.J. No. L123, 24.4.98, p. 1.

(39)

OJ No. L147, 9.6.1975, p.40.

(40)

OJ No. L200, 30.7.1999, p.1.